Professional Documents
Culture Documents
AIT 501 Instruction Manual-1
AIT 501 Instruction Manual-1
Arrow Button
value. The Meter can save up to 18 sets.
Arrow Button
previous
Arrow Button
voltage range.
voltage input terminal
(Connected to two-plug red test lead)
1 pc
1 pc test ( Connected to two-plug red test lead )
next voltage
leads and power adaptor with the same range.
One-plug 1 pc model or identical electrical specifications. (Connected to one-plug black test lead)
8 pcs
Two-plug
1 pc
One-plug
1 pc
One-plug
1 pc
1 pc
When compare function is enabled for
insulation resistance measurement,
measurements
almost
necessary. Under this status, the Meter
can still output 500V and 1000V to
measure, the measured accuracy will
not be affected.
This
When charging battery is applied, the charging battery
work mode should be selected at the startup: Press and
hold USB button prior to startup, then press down ON/
The Meter defaults at
OFF, LCD screen will display CHA or GEN, and select
to display CHA by pressing the up/down key, after 500V range and under continuous measurement of
pressing USB key to confirm, the Meter successfully insulation resistance when turned on.
enters the charging battery work mode. GEN means
the general alkaline battery work mode.
AIT 501 USERS MANUAL
the
Caution
the test
voltage output will be turned off and the
step
readings.
General Specifications
Calculation Tips:
PI = 3-minute ~ 10-minute resistance/30-second ~
1-minute resistance
18 sets
-1 14
compare value.
output
cause
personal injury.
AIT 501
voltage range.
AIT 501
AIT 501
Insert the red test lead into two LINE terminals,
the black one into GUARD and the green one Connecting USB Interface
into EARTH. See Figure 7 for USB interface connection.
green less
outputs
*END*
This operating manual is subject to change without notice.