Professional Documents
Culture Documents
● ● ● ● 2
Answer:D
28. If current flows from north to south in a
conductor placed over magnetic compass 34. Direction of force acting on a current
then north pole of magnetic compass with carrying conductor kept in a magnetic field is
point towards : given by :
(A) South (A) Fleming’s right hand rule
(B) North (B) Fleming’s left hand rule
(C) East (C) Lenz’s rule
(D) West (D) Faraday’s rule
Answer:C Answer:B
29. Important property of soft iron which 35. The most co7mmon device for providing
make it suitable for making the core of an an emf is :
electromagnet is : (A) Electric cell
(A) Strength (B) Generator
(B) It behaves as a magnet in presence of (C) Fuel cell
external magnetic field only (D) All of these
(C) Its melting point is high Answer:A
(D) None of these
Answer:B 36. Unit of a.c. is :
(A) ev
30. The magnetic field inside a solenoid is : (B) Ampere
(A) Zero (C) Farad
(B) Decreases along the axis (D) Fleming
(C) Increases along the axis Answer:B
(D) Uniform
Answer:D 37. The various distribution circuits are
connected in :
31. The polarity of an electromagnet depends (A) Series
on the : (B) Parallel
(A) Number of the turns in a coil (C) Series or parallel
(B) Direction of flow of current (D) Nothing can be said
(C) Nature of material Answer:B
(D) All are correct
Answer:B 38. We will receive an electric shock if we
touch
32. By increasing the number of turns in the :
coil, the strength of the magnetic field: (A) Live wire
(A) decreases (B) Neutral wire
(B) increases (C) Earth wire
(C) first increases then decreases (D) Any of the above
(D) remains unchanged Answer:A
Answer:B
39. The touching of the live wire and neutral
33. The emf produced in a wire by its motion wire directly is known as :
across a magnetic field does not depend upon (A) Power rating
: (B) Short circuit
(A) The length of the wire (C) Over loading
(B) The composition of the wire (D) None of these
(C) The speed of the wire Answer:B
(D) The orientation of the wire
● ● ● ● 3
40. Electricians use rubber gloves while
working because : 43. Electric power is transmitted over long
(A) Rubber is an insulator distance through conducting wires at very
(B) Rubber is a good conductor high voltage because :
(C) It is easy to work while wearing gloves (A) The power losses are reduced to minimum
(D) None of these (B) Signal of high voltage travel faster
Answer:A (C) High voltage can be stepped down to desired
levels easily
4. Why copper wire cannot be used as a fuse (D) None of these
wire : Answer:A
(A) Copper wire will get warm
(B) Copper wire has melting point quite high and 44. Birds do not feel electric shock while
it will not melt easily sitting on a current carrying uninsulated wires
(C) Copper wire melts easily due to overloading because :
(D) None of these (A) The current does not pass through the body
Answer:B as the claws of birds are non-conducting
(B) The resistance offered by the body of birds is
42. Which of the following effects of current very high
does not depend on direction of current : (C) The feathers of birds act as an insulator and
(A) Lighting and chemical effect hence current does not pass through them
(B) Heating and lighting effect (D) The potential difference between the two
(C) Heating and magnetic effect claws of birds is very small
(D) Magnetic and chemical effect Answer:D
Answer:B
● ● ● ● 4