RTV sealant to the rear cover, block, front cover, and block mounting faces.
The bead must extend the full
width of the flange.
Install a new oil pan gasket.
Capscrews 1 through 6 are longer
than the rest of the oil pan capscrews to accommodate the thickness of the clamping plate.
Install and finger tighten one of the
11.0 mm [7/16 in] oil pan mounting capscrews on each side of the oil pan, halfway between the front and the rear of the oil pan. Install the clamping plate and capscrews.
Install the flywheel housing dust
seal under the correct oil pan capscrews.
Install and finger tighten the
remaining capscrews.
Tighten the four 8 mm [5/16 in]
capscrews in the rear of the oil pan in the sequence illustrated.