Professional Documents
Culture Documents
PONE-OD55-DC en 01
PONE-OD55-DC en 01
Product Compact 2-port power injection device, capable for indoor and
Information outdoor installations where DC power supply is available.
An optional mounting kit is available for pole installation.
1
Using the OSDR radio, which supports two PonE IN ports.
1
Outdoor High-Power over Ethernet Injector (DC Input)
Datasheet – Edition 1.0
Characteristics Generic:
• DC version injector for use with DC power supply sources.
• DC input voltage range: 40 V to 60V.
• Up to 60 W output power (guaranteed).
• One 100/1000Base-T (R-J45) interface and one 100Base-
T (RJ-45) interface for management only.
Functionality:
• Load detection – the PonE injector continuously monitors
the load connected to its output (i.e. the current on the
Ethernet line). If the load is within the specified limits, the
output is up. If it is outside the limits (low load, no load,
high load or short circuit), the output turns off, then it
restarts automatically and it’s up again once it detects a
valid load at the output.
• Proprietary detection, disconnect and overload protection.
• Diagnostic LED.
• Full protection (OCP, OVP).
• Single source four-pair power current sharing.
Mechanical / Environmental:
• Dimensions: 170 mm x 150 mm x 39 mm.
• Operating temperature: -50 °C to +65 °C.
• Operating humidity: up to 93%.
• Suitable for indoor and outdoor installations – IP55 grade.
2
Outdoor High-Power over Ethernet Injector (DC Input)
Datasheet – Edition 1.0
Connections
1 2 3
3
© INTRACOM S.A. TELECOM SOLUTIONS, 2015. All rights reserved.
All copyright, intellectual and industrial rights in this document and in the technical knowledge it contains are owned by INTRACOM S.A. TELECOM
SOLUTIONS and/or their respective owners. This document is made available to the end users only for their internal use. No part of this document nor
any data herein may be published, disclosed, copied, reproduced, redistributed by any form or means, electronically or mechanically, or used for any
other purpose whatsoever without the prior written approval of INTRACOM S.A. TELECOM SOLUTIONS. Information as well as drawings and
specifications contained in this document are subject to change without prior notice. All trademarks and copyrights mentioned herein are the property
of INTRACOM S.A. TELECOM SOLUTIONS and/or their respective owners. Any rights not expressly granted herein are reserved.
Printed in Greece.