Professional Documents
Culture Documents
home
Home - AutoCAD - Pro/ENGINEER - SolidWorks - CATIA - UGNX - I-DEAS - Solid Edge - TopSolid -
Geomagic
1 of 6 3/4/2012 6:56 PM
Working with the Hole Chart in Pro/ENGINEER http://www.kxcad.net/ptc/pdx21/usascii/ReferenceGuide/working_with_...
Creating Tables
1. Load the drawing DEMOPLATE.DRW and click HOLECHART > CREATE TABLES. If the option
ADV_TABLE_FORMATS is set to 1, a list of all bore types appears so you can select which bore
types should be listed in the new table. This option is set to 0 by default, so this list is not
displayed. PDX will search for all bore types that have been marked red in the active table
format.
2 of 6 3/4/2012 6:56 PM
Working with the Hole Chart in Pro/ENGINEER http://www.kxcad.net/ptc/pdx21/usascii/ReferenceGuide/working_with_...
2. After selecting the reference coordinate system CS0, you must specify one or more
directions. Only bores with axes along the selected directions are accepted.
3 of 6 3/4/2012 6:56 PM
Working with the Hole Chart in Pro/ENGINEER http://www.kxcad.net/ptc/pdx21/usascii/ReferenceGuide/working_with_...
3. To automate the direction selection, set the configuration option DIR_DEFAULT to one of the
following directional values:
-Z
+Z and -Z
+X/-X/+Y/-Y/+Z/-Z
The hole chart will examine the geometry of the model to find all bores.
In the next example, the configuration parameter TABLE_PER_TYPE is set to 1, which means a
separate table or ASCII file is created for each bore type:
4 of 6 3/4/2012 6:56 PM
Working with the Hole Chart in Pro/ENGINEER http://www.kxcad.net/ptc/pdx21/usascii/ReferenceGuide/working_with_...
For CB_DBL the special format CB_DBL is used in which the other bores are written to tables with the
default format. If the hole chart cannot identify a bore type and the option SUPRESS_UNKNOWN is set
to 0, all unidentified bores are written to a table as TYPE ?. If you use ADV_TABLE_FORMATS, this
option must be set to 1.
Deleting Tables
Two options are available for deleting tables:
If you select a view, all corresponding tables are deleted.
If you select a table, only this table and its associated notes are deleted.
5 of 6 3/4/2012 6:56 PM
Working with the Hole Chart in Pro/ENGINEER http://www.kxcad.net/ptc/pdx21/usascii/ReferenceGuide/working_with_...
Updating Tables
The hole chart is based on feature recognition. Associativity between the table and part dimensions
is not possible. If any values are changed in the model, you must update the tables manually when
you return to the drawing.
Note: If the file creation options are set to 1, you are prompted to type the file name for each table
that is updated. In addition, if CREATE_TABLES_IN_UPDATE is set to 1, new tables are created for
bores that were not previously listed in an existing table and matched to a hole direction.
home
Your Ad Here
?? | ???
6 of 6 3/4/2012 6:56 PM