Professional Documents
Culture Documents
15A
Pin 1
DIAG
CS / UART / MS2
SCLK / MS1
MOSI / MS0
MISO / RST
15A
SLP
V_BUS
USBC
15A
STANDALONE
MS2
MS1
MS0
NORMAL MODE
HIGH / 1
Jumpers need to set up to
the micro-step you want RST DIAG PIN FROM DRIVER
per the manufactures docs.
LOW / 0 0 1 2 3 4 5 6 7
The Octopus manual states if
SLP
STOP CONNECTED TO
Only one jumper is needed for WHEN JUMPER IS INSTALLED
this mode.
RST
LOW / 0
SLP
SPI MODE
SCLK
MISO
MOSI
CS
required to use a PT100 with this board. One INA826AIDR POWER SUPPLIES TOGETHER, AND THIS WILL DAMAGE THIS BOARD.
chip is needed in the package type SOP-8 soldered in THE SAME RESULT CAN HAPPEN IF A JUMPER IS PLACED VERTICALLY. Motor 0 Motor 1 Motor 2 Motor 3
SENSOR
place near J47. J58 - J66: FAN VOLTAGE SLECTION VOLTAGE
WARNING!!
As of 2021-May 21, I am not finding them in stock. ONLY PLACE ONE JUMPER ACROSS THE SENSOR VOLTAGE SELECTION
HEADER, ANY MORE THAN ONE CAN CONNECT TWO/THREE
POWER SUPPLIES TOGETHER, AND THIS WILL DAMAGE THIS BOARD.
THE SAME RESULT CAN HAPPEN IF A JUMPER IS PLACED HORIZONTALLY.
Motor 4 Motor 5 Motor 6 Motor 7
This information was solely put together from BigTreeTech documentation and experience with BTT boards; I haven’t had one in my hands as of the date of this document. North Alabama PC (Thomas White) 2021-May-21st.