Refer to Troubleshooting, "Steering System" and Troubleshooting,
"Sensor Signal (PWM) - Test". in this manual. Autolube grease reservoir is low. Low Auto Lube E234 (1) Refer to M0079258 Systems Operation, Testing and Adjusting , Grease level Autolube. Charge Pressure was observed going abnormally low during operation. Thisis an indication of potential pump failure or wearout. Machine damage may occur if the machine continues to run, even at idle. Step 1: Check the charge filter for material such as brass or other metal particles. If metal is found, inspect the pump and motors. Step 2: Check the charge pressure at 1800 rpm engine speed, with the gear selector in NEUTRAL. Fully press the left pedal and check charge pressure in both FORWARD and REVERSE at high idle. If Low Hydraulic Charge E283 (2) low, contact your Cat dealer Technical Communicator (TC). For Pressure further assistance, your TC can confer with the Dealer Solutions Network (DSN). Step 3: If no problems were found, download a Product Status Report (PSR) and engine data file. Contact your Cat dealer Technical Communicator (TC). For further assistance, your TC can confer with the Dealer Solutions Network (DSN) to determine if this is a trend, or a one-time occurrence. Step 4: Investigate for reverse fan solenoid or brake charging issues. Low Brake E284 Same logic as E1561 (2S), but only occurs when the warning is Accumulator (2S) ignored and the machine speed exceeds 8 kph (5 mph). Pressure Immediate Safe Shut Down of Machine Required. Activates when the brake system pressure drops below the BRAKE ACCUMULATOR PRESSURE LOW threshold for 2 seconds. One of the following pre-conditions must also be met:
1. The engine has been running stable for 60 sec.
2. The engine exceeded the BRAKE ACCUMULATOR PRESSURE Low Brake OK threshold after engine cranking. E284 (3) Accumulator Pressure Brake accumulator pressure OK threshold for 926 / 930 is 11721 kPa (1700.01 psi). Brake accumulator pressure OK threshold for 938 is 12058 kPa (1749 psi). Brake accumulator LOW threshold for 926 / 930 is 10515 kPa (1525.1 psi). Brake accumulator LOW threshold for 938 is 10852 kPa (1574 psi). E329 (2) Transmission Filter Activates when the transmission oil filter bypass switch has been Plugged bypassing for 5 or more seconds with transmission oil temperature > 50° C (122° F)and engine running. Event deactivates with machine shutdown or switches no longer bypassing.
Transmission filter is plugged or restricted - replace the filter.