cK 1.86.00
.
castes,
a] eva" fischer
sevn22022
innovative solutions
Tischer FZE
Jebel Ali Free Zone Warehouse No XB
P.O. Box 261738 Dubai
Enquiry@tscherae
worischer ae
Comment
[Check Anchor bolt adequecy for fixing Screen barrier
Design Specifications
Anchor
‘Anchor system fischer Bolt anchor FAZ I
‘Anchor Bolt anchor FAZ II 8/10, zinc plated stel ==
Calculated anchorage 35 mm
cept
Design Data ‘Anchar design in Concrete accarding European Technical Ce
‘Assessment ETA-05/0083, Option 1,
Issued 03/07/2017
Geometry | Loads / Scale units,
rm,
Vat of design stn tnctang _
partial safety factor for the load)
Not drawn to seale
“The abu values and ia Geign rus SHOWS be Checad spar cal valid Saas and appa Please epost Ta Sadaivar TWAT
the lange agreemer fhe Sofware
Page 1=
cK 1.86.00
Dataoase version
2020.27.18.43
Date
sevn22022
innovative solutions
Input data
Design methoa
Base material
Concrete condition
Reinforcement
Driting method
Installation type
‘Annular gap
‘Type of loading
Base plate location
Base plate geometry
Profle type
‘TROSS/ETAG 001, Annex C, Method A
Normal weight concrete, C20/25, EN 208
Cracked, dry hole
No or standard reinforcement. No edge reinforcement. With
reinforcement against splting
hammer ailing
Push-hrough installation
‘Annular gap not filed
Static or quasistatic
Base plate flush installed on base material
50 mm x 50 mm x 6 mm
None
Design actions *?
# Nee Vea Veuy | Mex May Misa ‘ype of loading
aN KN KN km kN Nm
788 bas 208 2.00 200 0.00 Siac or quasi
Th eg part sft fos for acne anced
Resulting anchor forces
Tensiieaction ShearAcllon _ ShearActionx Shear Action y
Anchor no. kN nv kN kN
‘max. concrete compressive strain 0.00
‘max concrete compressive stress 0.0 Nimm?
Resulting tensile actions
Resulting compression actions
sistance to ten:
1.86 KN, XIY position (0/0)
0.00 KN. XIY position (0/0)
Action Capacity Utilisation By
Proof KN kn %
‘Steet ae 785 TF 7e8 |
TT Vlone BT ST RE SNOUE Bs CHGS BRT aT GTS HACHETTE, PAGS SDRC GCE TWA
the lange agreemer fhe Sofware
Page 2cK 1.86.00
Dataoase version
2020.27.18.43
Date
sevn22022
fischer
innovative solutions
News on Nisa
a kN
Bes
Anchor no. ” GroupN* Decisive Beta
7 Tee 7 Ba
News Y We Nate Nes Pre
a kN kN %
‘The given Psic-actor may has been determined by interpolation.
Pro
Anchor no. % GroupN*___ Decisive Beta
Nite = Nie Wye? Woes cere
ew 2 2 .
Nowe = TA5KN 1.000 1.000: 1.000 = 7.45K1V
T1,025memn?
Nice = Br Vf
2. YOR. (
(07
Yow = 1.000
ee
03
Simm) = 1000 <1 se
TT Vlone BT ST RE SNOUE Bs CHGS BRT aT GTS HACHETTE, PAGS SDRC GCE TWA
the lange agreemer fhe Sofware
Page 3cK 1.86.00
Dataoase version
2020.27.18.43
Date
sevn22022
fischer ==
innovative solutions
Yeoy = Pas > Wee = 1.000: 1.000 = 1.000 < 1
1
Youse = = 100 51 Yaasy = = 1.000 <
i i
Nine wm Maus Nes Bs
‘a i A es
Pee
Ancor no. e3 Group i” __ Decisive Bata
Resistance to shear loads
Prot aon Capacity | —Uuieaton
iN "a %
Seale aa waren om rae 30
Geet yo ire at aie ar
te
dj
Vas vm Vaws Vee fw
f i a es
be
Anhor no. % Group W"__becisve Bata
1 30 1 Bs |
TABRN' = 18.64KN
TT Vlone BT ST RE SNOUE Bs CHGS BRT aT GTS HACHETTE, PAGS SDRC GCE TWA
the lange agreemer fhe Sofware
Page 4cK 1.86.00 =
Dataoase version
Date
erizeanaa innovative solutions
1.000 1.000. 1.000 = 7.45K1V
Nie
= TASK
Yow = 1.000 29
Veaw = 7 =F Weoaies Veory = 1.000- 1,000 = 1.000 < 1 20,
Vase Ye Veco Vs Buse
aN fo RN %
Puce
Anchor no. % GroupN"___Decisive Beta
t 2 1 Bust
Utilization of tension and shear loads
Tension loads Utilisation BN] Shear Loads Utitsation BV
% %
Sertane™ 738 Tiel ale wine Taver a= 30
Plow ature” sos Conerete pry out talre 2r
Resistance to combined tensile and shear loads
Aly eee Proof successful cee
Hea) = A 3
Information concer! the anchor plate
Base plate details
Plate thickness specified by user without proof t= 8mm
Profle type None
TT Vlone BT ST RE SNOUE Bs CHGS BRT aT GTS HACHETTE, PAGS SDRC GCE TWA
the lange agreemer fhe Sofware
Pagesesi fischer
teri2reo2e innovative solutions
Technical remarks
{All data and information in the software is based on fischer products and common engineering knowledge. Pleas
check all the proof results against local valid standards and approvals
AAs fischer is not the design office, the attached is no guarantee for incorrect input or assumptions. Any
recommendations have to be approved by the bullding-authority or project engineer. Results are valid only for
anchor eystem calculated in the attached. If any part of the system is changed, it will invalidate this report and new
calculations would be required. The calculation was done under the assumption that a sufficient
splitting reinforcement is available, In this case the spliting
failure can be omitted.
The transmission ofthe anchor loads to the supports ofthe concrete member shall be shown forthe ukimate limit state and
the serviceability limit state; for this purpose, the normal verifications shall be carried out under due consideration of the
actions introduced by the anchors. For these verifications the additional provisions given in the current design method shall
be taken inte account.
‘As.a pre-condiion the anchor pate is assumed to be fat when subjected to the actions. Therefore, the plate must be
sufficiently stiff. The C-Fix anchor plate desighis based on a proof of stresses and does not allow a statement about
the stress of the plate. The proof of the necessary stiffness is not carried aut by C-Fbx.
During the design process, the following hints and warnings were issued:
+The anchor's tobe used only for multiple Fixings for non-structural applications,
“The abu values and ia Geign rus SHOWS be Checad spar cal valid Saas and appa Please epost Ta Sadaivar TWAT
the lange agreemer fhe Sofware
PagescK 1.86.00
.
saeatete,
sevn22022
innovative solutions
instal
Anchor
‘Anchor system
‘Ancor
Accessories
Installation details
Thread diameter
Dail hole diameter
Drill hole depth
Calculated anchorage
depth
Installation depth
Dailing method
Dill hole cleaning
Installation type
‘Annular gap)
Installation torque
Socket size
Base plate thickness
‘Total xing thickness
Thixmax
Base plate details.
Base plate material
Base plate thickness
Clearance hole in ba
Plate
Attachment
Profle type
Anchor coordinates,
Anchor ne mm
n_ data
fischer Bolt anchor FAZ Il
Bolt anchor FAZ Il 8/10, zine plated Art-No, 84871
steel
Biow-out pump ABG big Art-No. 6900
‘Quatre I 100/165 XPS |Art-No, 549989,
Erection ofthe drilhole by hammer
dling with or without suction
cleaning
Fem = 45 mm
hammer driling
only blow out by hand
Push-through installation
‘Annular gap not files
Toa = 20.0 Nm
13mm
fia max= 20 mm
Not available
429mm x
None * d
¥
3 ! eB
%
“The abu values and ia Geign rus SHOWS be Checad spar cal valid Saas and appa Please epost Ta Sadaivar TWAT
the lange agreemer fhe Sofware
Page?