You are on page 1of 16

1

Concrete Edge Breakout Check

Critical support reactions on most stressed anchor rod were obtained from Bottom Bracket Connection (BKT5) finite
element analysis attached in appendix A (Refer to MALL-TGAC-ML-GF-STR-CAL-00650)

Note: Software is used to check only the concrete edge breakout due to shear forces. Software design report is
attached for reference, refer to appendix B.

Software Input:

Force along x-axis F x  12.68kN

Force along y-axis F y  2.47kN

Actual concrete edge failure utilization βv  86 %

βv  100% "Therefore Ok"


2

APPENDIX A
3

+%27720%5$&.(7&211(&7,21 %.7

68332575($&7,216
Refer to attached Canopy Frame STAAD Support Reactions on page 20-22/22.

&DVH
Reaction along x-axis Rx1  3.84kN
Reaction along y-axis Ry1  8.60kN
Reaction along z-axis Rz1  19.17 kN

&DVH
Reaction along x-axis Rx2  3.81kN
Reaction along y-axis Ry2  12.10 kN
Reaction along z-axis Rz2  21.69 kN

:(/'&+(&.
Weld thickness tw  8.00mm
Weld throat size aw  0.707 ˜ tw 5.66˜ mm
Weld design strength pw  202.00MPa
Material factor γM  1.10
Weld depth dw  250.00mm
Weld breadth bw  150.00mm
Weld total unit length
Lw  2 dw  bw 800.00˜ mm

pw˜ aw˜ Lw
Weld allowable load wwall  830.92˜ kN
γM
Uniform load due to axial load
fzw  max Rz1 Rz2 21.69 ˜ kN

Uniform load due to vertical shear load fyw  max Ry1 Ry2 12.10 ˜ kN

76
4

Uniform load due to horizontal shear load


fxw  max Rx1 Rx2 3.84˜ kN

Actual weld load wact  § f 2  f 2·  f 2 25.13 ˜ kN


© yw xw ¹ zw
wwall d wact "Therefore OK!"

%$6(3/$7(&+(&.

67$$',QSXW

&DVH
Reaction along x-axis Rx1  3.84kN
Reaction along y-axis Ry1  8.60kN
Reaction along z-axis Rz1  19.17 kN
&DVH
Reaction along x-axis Rx2  3.81kN
Reaction along y-axis Ry2  12.10 kN
Reaction along z-axis Rz2  21.69 kN

See attached BKT#5 STAAD report!

$1&+25%2/7&+(&.

$QFKRU3URSHUWLHV
Diameter of Anchor do  16mm
2
π ˜ do 2
Effective cross sectional area of anchor Ase  0.75˜ 150.80˜ mm
4
Compressive Strength fc  40.00 MPa
Tensile Strength
3ODWH3URSHUWLHV futa  700.00MPa
Design Strength py  275.00MPa

77
5 Page 1 of 4

Job Information
Engineer Checked Approved

Name: SGT
Date: 08-Julr-19

Structure Type SPACE FRAME

Number of Nodes 2721 Highest Node 2730


Number of Plates 2849 Highest Plate 2907

Number of Basic Load Cases -2


Number of Combination Load Cases 0

Included in this printout are data for:


All The Whole Structure

Included in this printout are results for load cases:


Type L/C Name

Primary 1 CASE 1
Primary 2 CASE 2

Plate Thickness
Prop Node A Node B Node C Node D Material
(mm) (mm) (mm) (mm)
1 12.00 12.00 12.00 12.00 STEEL

0 .0
5
m 0m
0.030
m
0.180 0.1
0 .0 6 6m
50 30m
0.0
m

0.1
66
m
0.346m

m
0.150

m
0.240
0.250m

0 .2
16
m
0.119m

Y
X
Z Load 1

STRUCTURAL MODEL

78
6 Page 2 of 4

19.17 kN

3.84 kN

Y
X Load 1
Z
8.60 kN

LOAD CASE 1 DIAGRAM

-12.10 kN

-3.81 kN

Y
X Load 2
Z

-21.69 kN

LOAD CASE 2 DIAGRAM

79
7 Page 3 of 4

Max Absolute
MPa
<= 0.019 STRESS CHECK:
3.25 Maximum stress = 51.70MPa
6.48 Design strength S275 = py = 275.00MPa
9.72 Materia factor = MF = 1.1
12.9 Permissible strength = py/MF = 250.00MPa
16.2 Max. stress < Per. strength, "Therefore OK!"
19.4
22.6
25.9
29.1
32.3
35.6
38.8
42
45.3
48.5
>= 51.7

Y
X Load 1
Z

STRESS DIAGRAM (CASE 1)

Max Absolute
MPa
<= 0.009
2.75 STRESS CHECK:
5.5
8.24
Maximum stress = 43.90MPa
Design strength S275 = py = 275.00MPa
11
Materia factor = MF = 1.1
13.7
Permissible strength = py/MF = 250.00MPa
16.5
Max. stress < Per. strength, "Therefore OK!"
19.2
22
24.7
27.4
30.2
32.9
35.7
38.4
41.2
>= 43.9

Y
X Load 2
Z

STRESS DIAGRAM (CASE 2)

80
8 Page 4 of 4

X = -0.19 kN
Y = -0.01 kN
Z = 0.31 kN
X = -0.20 kN
Y = 0.02 kN
Z = -0.45 kN

X = -0.98 kN
Y = 0.14 kN
Z = -6.35 kN
X = -2.47 kN
Y = 0.12 kN
Z = -12.68 kN

Y
X Load 1
Z

SUPPORT REACTIONS (CASE 1)

X = 0.33 kN
Y = -0.50 kN
Z = -2.26 kN
X = 0.02 kN
Y = -0.47 kN
Z = -1.56 kN

X = 1.18 kN
Y = 0.66 kN
Z = 4.14 kN
X = 2.28 kN
Y = 0.60 kN
Z = 8.95 kN

Y
X Load 2
Z

SUPPORT REACTIONS (CASE 2)

81
9

Steel Strength of Anchor in Tension

Actual tension load per bolt Tb  0.12kN


(refer to attached BKT#5 STAAD Support Reactions)
Nominal Strength of Anchor inTension Nsa  Ase˜ futa 105.56˜ kN
Strength reduction factor ϕ  0.75
Design strength of anchor on tension Nsad  0.75ϕ˜ Nsa 59.38 ˜ kN

Tb d Nsad "Therefore OK!"

Steel Strength of Anchor in Shear

Actual shear load along x-axis per bolt Vx  2.47kN


(refer to attached BKT#5 STAAD Support Reactions)
Actual shear load along z-axis per bolt Vz  12.68 kN
(refer to attached BKT#5 STAAD Support Reactions)
2 2
Shear load per bolt V Vx  Vz 12.92 ˜ kN

Nominal strength of an anchor in shear Vsa  0.6˜ Ase˜ futa 63.33 ˜ kN

Design strength of an anchor in shear Vsad  0.75ϕ˜ Vsa 35.63 ˜ kN

V d Vsad "Therefore OK!"

V Tb
Interaction Ratio R  0.36
Vsad Nsad

R d 1.20 "Therefore OK!"


Bearing Check
Thickness of wall t  300.00mm
2
Bearing area Ab  0.75˜ do˜ t 3600.00˜ mm

V
Bearing of bolt to concrete fp  3.59˜ MPa
Ab
Nominal bearing of concrete Fp  0.85˜ fc 34.00 ˜ MPa

Reduction factor ϕ  0.60


Design bearing of concrete Fpd  ϕ˜ Fp 20.40 ˜ MPa

fp d Fpd "Therefore OK!"

Weld: 8mm thk. Weld


Base Plate Size: 12mm thk. Steel Base Plate S275
Anchor Bolt: 2 Nos - 16mmࠕ Threaded Rods with Nuts
NOTE: Provide non-shrink grout for the holes

82
10

APPENDIX B
11

www.hilti-me.com Profis Anchor 2.8.5


Company: Page: 1
Specifier: Project:
Address: Fastening Point:
Phone I Fax: | Date: 24/11/2019
E-Mail:

Specifier's comments:

1 Input data
Anchor type and size: HIT-HY 200-R + HIT-V-R M16
Seismic/Filling set or any suitable annular gap filling solution
Effective embedment depth: hef,act = 114 mm (hef,limit = - mm)
Material: A4
Approval No.: ETA 12/0084
Issued I Valid: 07/08/2019 | -
Proof: SOFA design method + fib (07/2011) - after ETAG BOND testing
Stand-off installation: eb = 0 mm (no stand-off); t = 12 mm
Baseplate: lx x ly x t = 200 mm x 120 mm x 12 mm; (Recommended plate thickness: not calculated
Profile: no profile
Base material: cracked concrete, C40/50, fc,cyl = 40.00 N/mm2; h = 150 mm, Temp. short/long: 30/40 °C
Installation: hammer drilled hole, Installation condition: Dry
Reinforcement: No reinforcement or Reinforcement spacing >= 150 mm (any Ø) or >= 100 mm (Ø <= 10 mm)
with longitudinal edge reinforcement d >= 12 + close mesh (stirrups, hangers) s <=

R
- The anchor calculation is based on a rigid baseplate assumption.

Geometry [mm] & Loading [kN, kNm]

Input data and results must be checked for agreement with the existing conditions and for plausibility!
PROFIS Anchor ( c ) 2003-2009 Hilti AG, FL-9494 Schaan Hilti is a registered Trademark of Hilti AG, Schaan
12

www.hilti-me.com Profis Anchor 2.8.5


Company: Page: 2
Specifier: Project:
Address: Fastening Point:
Phone I Fax: | Date: 24/11/2019
E-Mail:

2 Load case/Resulting anchor forces y


Load case: Design loads

Anchor reactions [kN]


Tension force: (+Tension, -Compression)
Anchor Tension force Shear force Shear force x Shear force y
1 0.000 12.918 12.680 2.470
x
max. concrete compressive strain: - [‰]
max. concrete compressive stress: - [N/mm2]
1
resulting tension force in (x/y)=(0/0): 0.000 [kN]
resulting compression force in (x/y)=(0/0): 0.000 [kN]

Anchor forces are calculated based on the assumption of a rigid baseplate.

3 Tension load SOFA (fib (07/2011), section 16.2.1)


Load [kN] Capacity [kN] Utilisation bN [%] Status
Steel failure* N/A N/A N/A N/A
Combined pullout-concrete cone failure** N/A N/A N/A N/A
Concrete cone failure** N/A N/A N/A N/A
Splitting failure** N/A N/A N/A N/A
* most unfavourable anchor **anchor group (anchors in tension)

Input data and results must be checked for agreement with the existing conditions and for plausibility!
PROFIS Anchor ( c ) 2003-2009 Hilti AG, FL-9494 Schaan Hilti is a registered Trademark of Hilti AG, Schaan
13

www.hilti-me.com Profis Anchor 2.8.5


Company: Page: 3
Specifier: Project:
Address: Fastening Point:
Phone I Fax: | Date: 24/11/2019
E-Mail:

4 Shear load SOFA (fib (07/2011), section 16.2.2)


Load [kN] Capacity [kN] Utilisation bV [%] Status
Steel failure (without lever arm)* 12.918 35.256 37 OK
Steel failure (with lever arm)* N/A N/A N/A N/A
Pryout failure** 12.918 35.469 37 OK
Concrete edge failure in direction x+** 12.918 15.046 86 OK
* most unfavourable anchor **anchor group (relevant anchors)

4.1 Steel failure (without lever arm)


VRk,s [kN] gM,s VRd,s [kN] VSd [kN]
55.000 1.560 35.256 12.918

4.2 Pryout failure (bond relevant)


Ap,N [mm2] A0p,N [mm2] y A,Np
2
t Rk,ucr,25 [N/mm ] ccr,Np [mm] scr,Np [mm] cmin [mm]
83,781 116,964 0.716 15.00 171 342 90
2 0
yc t Rk,cr [N/mm ] max t Rk,cr [N/mm2] k4 y g,Np y g,Np
1.079 7.55 10.34 2.000 1.000 1.000
ec1,V [mm] y ec1,Np ec2,V [mm] y ec2,Np y s,Np y re,Np
0 1.000 0 1.000 0.858 1.000
N0Rk,p [kN] NRk,p [kN] gM,c,p VRd,cp [kN] VSd [kN]
43.290 26.602 1.500 35.469 12.918

4.3 Concrete edge failure in direction x+


lf [mm] dnom [mm] kV a b
114 16.0 1.700 0.087 0.064
c1 [mm] Ac,V [mm2] A0c,V [mm2] y A,V
150 47,250 101,250 0.467
y s,V y h,V y a,V ec,V [mm] y ec,V y re,V y 90°,V
0.820 1.225 1.010 0 1.000 1.400 1.500
V0Rk,c [kN] gM,c VRd,c [kN] VSd [kN]
34.045 1.500 15.046 12.918

5 Displacements (highest loaded anchor)


Short term loading:
NSk = 0.000 [kN] dN = 0.000 [mm]
VSk = 18.874 [kN] dV = 0.755 [mm]
dNV = 0.755 [mm]
Long term loading:
NSk = 0.000 [kN] dN = 0.000 [mm]
VSk = 18.874 [kN] dV = 1.132 [mm]
dNV = 1.132 [mm]

Comments: Tension displacements are valid with half of the required installation torque moment for uncracked concrete! Shear displacements
are valid without friction between the concrete and the baseplate! The gap due to the drilled hole and clearance hole tolerances are not
included in this calculation!

The acceptable anchor displacements depend on the fastened construction and must be defined by the designer!

Input data and results must be checked for agreement with the existing conditions and for plausibility!
PROFIS Anchor ( c ) 2003-2009 Hilti AG, FL-9494 Schaan Hilti is a registered Trademark of Hilti AG, Schaan
14

www.hilti-me.com Profis Anchor 2.8.5


Company: Page: 4
Specifier: Project:
Address: Fastening Point:
Phone I Fax: | Date: 24/11/2019
E-Mail:

6 Warnings
• The anchor design methods in PROFIS Anchor require rigid baseplates per current regulations (ETAG 001/Annex C, EOTA TR029, etc.).
This means load re-distribution on the anchors due to elastic deformations of the baseplate are not considered - the baseplate is assumed to
be sufficiently stiff, in order not to be deformed when subjected to the design loading. PROFIS Anchor calculates the minimum required
baseplate thickness with FEM to limit the stress of the baseplate based on the assumptions explained above. The proof if the rigid baseplate
assumption is valid is not carried out by PROFIS Anchor. Input data and results must be checked for agreement with the existing conditions
and for plausibility! 
• The accessory list in this report is for the information of the user only. In any case, the instructions for use provided with the product have to
be followed to ensure a proper installation.
• Drilled hole cleaning must be performed according to instructions for use (blow twice with oil-free compressed air (min. 6 bar), brush twice,
blow twice with oil-free compressed air (min. 6 bar)).
• Characteristic bond resistances depend on short- and long-term temperatures.
• Please contact Hilti to check feasibility of HIT-V rod supply.
• The design method fib (07/2011) assumes that no hole clearance between the anchors and the fixture is present. This can be achieved by
filling the gap with mortar of sufficient compressive strength (e.g. by using the HILTI Seismic/Filling set) or by other suitable means
• The compliance with current standards (e.g. EC3) is the responsibility of the user
• Checking the transfer of loads into the base material is required in accordance with fib (07/2011)!

Fastening meets the design criteria!

Input data and results must be checked for agreement with the existing conditions and for plausibility!
PROFIS Anchor ( c ) 2003-2009 Hilti AG, FL-9494 Schaan Hilti is a registered Trademark of Hilti AG, Schaan
15

www.hilti-me.com Profis Anchor 2.8.5


Company: Page: 5
Specifier: Project:
Address: Fastening Point:
Phone I Fax: | Date: 24/11/2019
E-Mail:

7 Installation data
Baseplate, steel: - Anchor type and size: HIT-HY 200-R + HIT-V-R M16
Profile: no profile Installation torque: 0.080 kNm
Hole diameter in the fixture: df = 18 mm Hole diameter in the base material: 18 mm
Plate thickness (input): 12 mm Hole depth in the base material: 114 mm
Recommended plate thickness: not calculated Minimum thickness of the base material: 150 mm
Drilling method: Hammer drilled
Cleaning: Compressed air cleaning of the drilled hole according to
instructions for use is required

7.1 Recommended accessories

Drilling Cleaning Setting


• Suitable Rotary Hammer • Compressed air with required • Dispenser including cassette and mixer
• Properly sized drill bit accessories to blow from the bottom of • Seismic/Filling set
the hole • Torque wrench
• Proper diameter wire brush

y
-50

100 100

60
90

x
30

60

1
30

50 150

Coordinates Anchor [mm]


Anchor x y c-x c+x c-y c+y
1 -50 -30 - 150 - 90

Input data and results must be checked for agreement with the existing conditions and for plausibility!
PROFIS Anchor ( c ) 2003-2009 Hilti AG, FL-9494 Schaan Hilti is a registered Trademark of Hilti AG, Schaan
16

www.hilti-me.com Profis Anchor 2.8.5


Company: Page: 6
Specifier: Project:
Address: Fastening Point:
Phone I Fax: | Date: 24/11/2019
E-Mail:

8 Remarks; Your Cooperation Duties


• Any and all information and data contained in the Software concern solely the use of Hilti products and are based on the principles, formulas
and security regulations in accordance with Hilti's technical directions and operating, mounting and assembly instructions, etc., that must be
strictly complied with by the user. All figures contained therein are average figures, and therefore use-specific tests are to be conducted
prior to using the relevant Hilti product. The results of the calculations carried out by means of the Software are based essentially on the
data you put in. Therefore, you bear the sole responsibility for the absence of errors, the completeness and the relevance of the data to be
put in by you. Moreover, you bear sole responsibility for having the results of the calculation checked and cleared by an expert, particularly
with regard to compliance with applicable norms and permits, prior to using them for your specific facility. The Software serves only as an
aid to interpret norms and permits without any guarantee as to the absence of errors, the correctness and the relevance of the results or
suitability for a specific application.
• You must take all necessary and reasonable steps to prevent or limit damage caused by the Software. In particular, you must arrange for
the regular backup of programs and data and, if applicable, carry out the updates of the Software offered by Hilti on a regular basis. If you do
not use the AutoUpdate function of the Software, you must ensure that you are using the current and thus up-to-date version of the Software
in each case by carrying out manual updates via the Hilti Website. Hilti will not be liable for consequences, such as the recovery of lost or
damaged data or programs, arising from a culpable breach of duty by you.

Input data and results must be checked for agreement with the existing conditions and for plausibility!
PROFIS Anchor ( c ) 2003-2009 Hilti AG, FL-9494 Schaan Hilti is a registered Trademark of Hilti AG, Schaan

You might also like