‘Fhotied States of America
Department of Cemsportation — Federal Aviation Adeninistration
Supplemental Type Certificate
Number St01050SE
This cartifeate, issued to Learjet, Inc.
One Learjet Way
Wichita, KS 67209
certifics that the change tn the ype design for the following product with the limitations and conditions
Uarefar as specified hereon meets the airworthiness reguirumants of Part 25 of the Federal Aviation
Tapulations
Gripinal Product pe Cartifrate Nunler: _ MOCE (Rev. 48)
Meke Learjet, Inc
Model 5SIS5BIS5C
Desarjrtion of the Gppe Design Change: Group opproval for Reduced Vertical Separation Minimum are
contained in AeroMech Document No AMI-QD-LJ-0120, Rev. “New,” dated February 28, 2002, or later FAA-
approved revisions.
Limitations and Conditions The \nsteuctions for Initial and Continued Airworthiness, document
AMI-STC-LJ5S, Rev. "NEW," dated February 2, 2002, or latest approved revision is a required part of this STC.
‘The Airplane Flight Manual Supplement (AFMS) for the Learjet Models 55 (SIN 55-001 to 55-126), AeroMech
Document LJ-02-558-1, Rev. “Original,” FAA Approved, February 28, 2002, is required on-board for operation of
these aircraft.
‘The AFMS for the Learjet Models S5B/C (SIN 55-127 to 55-147), AeroMech Document LU-02-55S-2, Rev.
“Original,” FAA Approved, February 28, 2002, is required on-board for operation of these aircraft.
Descriptive data pertaining to this design change are considered inadequate for duplication on other products.
This approval is limited to Learjet Models §5/55B/55C only.
A copy of this certificate must be maintained as part of the permanent records of the aircraft. If the holder agrees
to permit another person to use this certificate the holder shall give the other person written evidence of the
permission,
This certificate and the supporting data which is the basis for approval hall/ramain in offeet untill
surrindeved, sponded, revoked, ora termination date is otherwite established by the Seninisioator of the
Gederal oiation Mdminisivation
Bate of spplesation: Ocover 23, 2001 Date rsueds
rae of suance: February 28, 2002 Date amended Match 26, 2002
By darecton of the Sedminisirator
Acting Manager, Soaitle Alrcraft
Cerlfication Office
(Tie)
‘Any alteration of this certificate is punishable by a fine of not
exceeding $1,000, or imprisonment not exceeding 3 years, or both
Ths cerificce may be transfered in accordance with FAR 217.INSTRUCTIONS; The transfer endorsement below may be used to notify the appropriate FAA Regional Office of
the transfer of this Supplemental Type Certifiate
“The FAA will reissue the certificate in the name of the transferee and forward it wo him.
ee
TRANSFER ENDORSEMENT
“Transfer the ownership of Supplemental Type Certificate Number STO1050SE ___
to (Name of transfoee) Learjet Inc ——
(Adérss of tronsfoee)-Qne Learjet Way
[amis oo ty
Wichita, Kansas 6729@
(Gin, Sia, aad IP eae]
from (Name of grantor) (Print or ppe) —-BeroMech Incorporated
(Address of grantor) 1616 Hewitt Avenue, Suite 312
Everett WA 98201
(Cap Sam dF ee)
Extent of Authority (if licensing agreement):
Jeane, Tove