Professional Documents
Culture Documents
Step 1: Connect the console cable from the switch console port to the PC USB
port. Refer to the diagram below.
Step 2: Connect all the devices using straight-through Ethernet cable. Refer to the
diagram below.
Step 3: Turn on the Cisco Catalyst 3750 v2 series switch.
Step 4: On the PC (where the PuTTY software is installed), open Device Manager
and click Ports (COM & LPT) to look for the correct port number where your
console cable is plug-in.
Step 5: Open PuTTY, click the radio button of the serial under the connection
type, and then change the serial line to COM3 (if it is in the COM3 port). After
that, click open.
Step 6: After you click the open button, it will activate the Command Line
Interface (CLI). It will display a message "Would you like to enter the initial dialog?
[yes/no]:" and say no by typing “n”. And press Enter, and the Switch> prompt will
appear, which is called user exec mode (user mode).
Click “Use the following IP address” and manually input the IP address,
Subnet mask, Default gateway, and DNS server.
Step 9: Display each computer's basic TCP/IP Network Information (IP, subnet
mask, gateway) using a command prompt (CMD).
Step 10: Ping all computers to check if all other devices are reachable using the
command prompt.
Step 11: Group the computers into two groups.
Step 12: Create two VLANs on the switch.