Professional Documents
Culture Documents
Service Description
Install and setup of a CoinFlip Bitcoin ATM kiosk. You will be required to drill and tap anchors into the floor
and secure the kiosk in place using the provided hardware. Once mounting process is finished and the
kiosk is connected to power, a brief setup and test phase will follow, which may include troubleshooting
any problems that arise, if necessary. Finally, the kiosk is to be locked and secured, and the keys are to
be returned via UPS or FedEx with the included prepaid label.
This work order REQUIRES a delivery before work can begin! Do not head to field site without
verifying that the kiosk has been delivered first. Verify delivery using provided tracking number.
Secondary contact info: If the Work Order Manager is not available, then you may alternatively contact
the CoinFlip Field Ops Technical Support line at (312) 971-3547.
Provided Equipment:
4. Locate the keys. They are in a cavity on the backside of the machine, covered by masking tape:
7. Fold down wire clips at the bottom of the battery sled in order to insert the batteries:
9. Fold the wire clips back up and snap them into place, then push the silver ring back into place:
11. Press 97* on the keypad to verify time set. The date will be displayed in DD/MM/YY format and
the time should be formatted in LOCAL MILITARY TIME. If the date or time is incorrect, contact
the Work Order Manager to coordinate another time set (take photo of date and time display
for your required deliverables):
13. Plug the kiosk into power Plug the kiosk into power using the main power cable from the rear of
the unit as soon as possible to allow the router to dial in and get a connection.
15. Position the CoinFlip Bitcoin ATM kiosk into place designated by store owner/manager. Before
drilling any holes, ensure that the main vault door AND the kiosk head door can both open
through their FULL range of motion, and are not blocked by any other objects. To open the
kiosk head door, use the yellow key. The lock cylinder for the kiosk head is on the right side of the
head of the machine. Ensure that access to this lock cylinder is not blocked by any other objects.
18. Hammer down anchors until there is less than 1.5 in of anchor remaining above floor level. DO
NOT hammer the anchors down with the nuts sitting at the top of the anchor or you will damage/
strip the threads on the anchor. There is a crumple zone at the top of the anchor that will allow
some mushrooming out of the metal while still allowing the nut to be threaded on properly:
20. Once the machine has booted up and established a connection, the CoinFlip customer interface
should be visible on the main screen:
24. You’ll be required to enter a phone number that can receive text messages in order to receive a
confirmation code:
26. Scan the test code on the code reader on the top left of the machine and insert cash into the bill
acceptor:
28. Install provided promotional items: small door cling, large window cling, poster, banner, yard
sign. Take photos of all installed promo items. (if site does not allow, a MOD name/signature is
needed)
30. Finally, remove any reference masking tape/QC stickers from machine before leaving the job site:
Install Checklist:
________________________________________________________________________________________
Signature: Date:
________________________________________________________________________________________