Professional Documents
Culture Documents
Engine Room Trim - 120224
Engine Room Trim - 120224
Snap button A
Engine room right trim panel Engine room left trim panel
Snap button B
1. Remove the snap buttons (B) (five) on the flat headed screwdriver first (as
upper cover board of the griller with a flat shown in the picture below; one on
headed screwdriver, and then press the left and one on right respectively);
circle in the center of the snap button (A) 2. Lift one side of the ventilating cover
with fingers to remove the snap buttons (left or right), and remove the clamp
(A) from the engine room left/right trim pins (six) shown in the picture.
panel and engine trim panel; Note: Do not apply too much force
2. Take out the engine room trim panel from to avoid damaging the clamp pins.
the engine room; 3. Pull out the ventilating panel along
3. Then, remove the corresponding plug in the front windshield. The installation
left/right trim panel and the small sequence is reverse to
decoupler of the engine room trim panel. removing.
The installation is reverse to the removing. Removing/installing left/right manhole
Ventilating cover cover of the ventilating cover:
Before removing the ventilating cover, first
remove the main and auxiliary wiper arms of
the front wiper assembly; refer to Wiper
Removal for details;
1. Remove the snap button (A) with a
1
BYD S6 Maintenance & Repair Manual
卡脚
Clamp pin