You are on page 1of 46

MAGNETIC FLOWMETERS

No BY DATE REVISION

Meter Tag. No. 1


Service agua

Location 1
Line size, Sched 1"
CONN´S Line Material Acero inoxidable
Connetion Mat´Is Brida
Tube Material Acero inoxidable
Liner Material Acero al carbono
Electrode Type STD
Electrode Matl. Hastelloy C22
METER Meter Casing STD
Power Supply Elect. Code 85-265V 60Hz
Anillo de acero
METERING Grouding Type & Matl. inoxidable
ELEMENT Enclosue Class 120V

Fluid Agua
Max. Flow Units 60 L/min
Max Velocity, Units 120 m/min
Norm. Flow Min. Flow 40L/min 20 L/min
FLUID
Max. Temp Min. Press. 122°F 16 bares
Min. Fluid Conductivity 0.073
Vacuum Posibility

Instrument Tag Number 1


Function Transmisor
Mounting Integrada
Enclossure Class 4X
Lenght Signal Cable 70mm
Type Span Adjustment Ciega
Power Supply 120
Transmiter Output 30V 220 mA
TRANS.

Scale Size Range


Chart Drive Speed ELECT 1200
DISPLAY
Chart Range Chart No
Integrator
Modes Output In electronica
CONTR.
CONTR. Action Auto-Man DEC switch

Contact No. Form


ALARM Rating Elec. Code
Action
Manufacturer ABB
Meter Model No. OIML R49-1
Secondary Instr. Model No. OI/FET100–IT
NOTES:
SHEET __1___ OF__1__
OWMETERS
SPEC. NO. REV
REVISION
CONTRACT DATE

REQ. P.O.

BY CHK´D APPR.

Tag number
Service

Meter Location
Line Size
End Connections
Body Rating
Nominal Flow Range
Accuracy
Linearity
K Factor, Cycles per Vol. Unit
Excitation
METER Materials: Body
Support
Shaft
Flanges
Rotor
Bearings: Type
Bearing Material
Max. Speed
Min. Output Voltage
Pickoff Type
Enclosure Class

Fluid
Flow Rate: Min Max.
Normal Flow
Operating Pressure
Back Pressure
FLUID DATA
Operating Temp. Max. Min.
Operating Specific Gravity
Viscosity Range
Percent Solids and Type

Secondary Instr. Tag No.


Preamplifier
Function
SECONDARY INSTR.
Mounting
SECONDARY INSTR.
Power Supply
Scale Range
Output Range
Totalizer Type
Compensation
OPTIONS Preset Counter
Enclosure Class
Strainer Size and Mesh

Manufacturer
Meter Model No.
Secondary Instr. Model No.
NOTES:
SHEET __1__ OF__1__
TURBINE FLOWMETERS
SPEC. NO.
NO. BY DATE REVISION
CONTRACT

REQ. P.O.

BY CHK'D

0-16 m3/s
+/-0.4%

Acero al carbono

Plastico FEF
Acero al inoxidable

4mA

-
6%
ABB
FEW111025A1D3A1B1A1A0A1B3A1
__1__ OF__1__
REV. PRESSURE CONTROL
and R

DATE NO

APPR.

Tag No. PV-2A


Service Air
GENERAL Line No./Vessel No. -
Line Size/Sched. No. -
Function Air-to-close
Type of Body High capacity globe
Body Size Port Size 25 mm 1"
Guiding No. of Ports - 2
End Conn. & Rating -
Body Material Carbon steel
Packing Material Any
BODY Lubricator Iso. Valve - 150 ASME RF
Seal Type Contoured, soft seat
Trim Form Contoured
Trim Material Soft seat
Seat Material Stainless steel 316L ST
Required Seat Tightness -
Max. Allow Sound Level dbA max 25 dBA
Type of Actuator Spring diagraphragm
Pilot -
Supply to Pilot 33 psi
Self Cont. Ext. Conn. - -
ACTUATOR / PILOT Diaphragm Material Stainless steel 316L ST
Diaphragm Rating -
Spring Range 11-23 psi
Set Point According to process

Filt. Reg. Supply Gage - -


Line Strainer -
Housing Vent -
ACCESORIES
Internal Relief -

FLOW UNITS LIQUID


Fluid
Quant. Max Cv

SERVICE
Quant. Oper. Cv
Valve Cv Valve FL
Norm. Inlet Press. ΔP
Max. Inlet Press.
SERVICE
Max. Shut Off ΔP
Temp. Max. Operating
Oper. sp. gr. Mol. Wt.
Oper Visc. % Flash
% Superheat % Solid
Vapor Press. Crit. Press.
Predicted Sound Level dBA
Manufacturer
Model No.
Notes:
PRESSURE CONTROL VALVES PILOTS SHEET __1___ OF___1__
and REGULATORS
SPEC. NO. REV.
NO BY DATE REVISION
CONTRACT DATE May
05th, 2022
REQ. P.O

BY CHK'D APPR.

PV-2B

Air
-
-
Air-to-open
High capacity globe
25 mm 1" GENERAL
- 2

Carbon steel
Any
- 150 ASME RF
XMTR
Contoured, soft seat
Contoured
Soft seat
Stainless steel 316L ST
-
CONTROLLER
max 25 dBA
Spring diagraphragm
-
33 psi
- -
Stainless steel 316L ST
-
11-23 psi
UNIT
According to process

- -
-
-
-

STEAM GAS

12 Cv 12 Cv
1.7 Cv 1.7 Cv
- - - -
- - - -

- - - -
- 232 °C 232 °C Notes:
- - - -
- - - -
- - - -
- - - -
max 25 dBA max 25 dBA
Masoneilan Masoneilan
87-21124
DIFFERENTIAL PRESSURE 1
SHEET ______ 1
OF______
INSTRUMENTS
SPEC. NO.
NO BY DATE REVISION
CONTRACT

REQ. P.O

BY CHK'D

Tag No. Service

Function Record Indicate Control Blind Trans Integ Other__________________


Case MFT STD Nom Size _______________ Color: MFR STD Other ____________________
Mounting Flush Surface Yoke Other ______________________________________________
Enclosure Class General Purpose Weather proof Explosion proof Class _______________________
For use in Intrinsically Safe System Other ___________________________________
Power Supply 117 V 60 Hz 10.5 to 42 Vdc
Other ac ________ dc _________ Volts _________________________
Chart 12 in. Circ. Other _____________ Range _________________ No. _________________
Chart Drive 24 hr Other _________________ Elec. Spring Other _____________________
Scale Type ____________________ Range: 1 _________ 2 __________ 3 __________________
Transmitter 4-20 mA 10-50 mA 21-103 kPa (3-15 psig) Other ______________
Output For Receiver, See Spec Sheet ___________________________________________________
Control Modes P= Prop ( Gain), I= Integral ( Auto Reset), D = Derivative (Rate)
Sub: s= Slow, f= Fast If Df P PI PD PID Is Ds
Other ______________________________________________________________________
Action On Meas. Increase Output: Increases Decreases
Auto-Man Switch None MFR STD Other ___________________________________________
Set Point Adj. Manual External Remote Other _____________________________
Manual Reg. None MFR STD Other ___________________________________________
Output 4-20 mA 10-50 mA 21-103 kPa (3-15 psig) Other __________________
Service Flow Level Diff. Pressure Other __________________________
Element Type Diaphragm Bellows Mercury Other __________________________
Material Body ________________________ Element _______________________________________
Rating Overrange ____________________ Body Rating ____________________ psig
Diff. Range Fixed Adj. Range ________________ Set At. _____________________________
Elevation _____________________________ Supression _________________________
Process Data Fluid ________________ Max Temp. ________________ Max Press. ________________
Process Conn. 1/2 in. NPT Ohter _____________________________________________________
Alarm Switches Quantity ______________ Form ______________ Rating ___________________________
Function Meas. Var. Derivation Contacts To ____________ on Inc. Meas.
Options Pressure Element Range __________________ Material ________________________
Temp. Element Range ___________________ Type __________________________
___________________________________________________________________________
Filt Reg. Sup. Gage Output Gage _______________ Charts
Valve Manifold ______________________________________________________________
Cond. Pots Adj. Damp Integral Sq. Rt. Ext.
Integrator __________________________________________________________________
Other _____________________________________________________________________

MFR & Model No. ___________________________________________________________________________


1
ET ______ 1
OF______
REV.

DATE May
05th
P.O

APPR.

________________
_________________
__________________
_________________
______________
42 Vdc
______________
______________
______________
______________
_____________
______________

_______________

_____________
_____________
_____________
_____________
____________
_____________
______________
sig
______________
______________
______________
______________
______________
as.
______________
______________
______________
s
______________
______________
______________

______________
TURBINE FLOWMETERS

NO. BY DATE REVISION

Tag number
Service
Meter Locati
Line Size
End Connecti
Body Rating
Nominal Flow 0-16 m3/s
Accuracy +/-0.4%
Linearity
K Factor, Cycl
Excitation
METER Materials: Bo Acero al carbono
Support
Shaft Plastico FEF
Flanges Acero al inoxidable
Rotor
Bearings: Typ
Bearing Mater
Max. Speed
Min. Output 4mA
Pickoff Type
Enclosure Cla

Fluid
Flow Rate: Mi
Normal Flow
Operating Pre
Back Pressure
FLUID DATA
Operating Tem
Operating Spe
Viscosity Ran -
Percent Solid 6%

Secondary Ins
Preamplifier
Function
SECONDARY INSTR.
Mounting
Power Supply
SECONDARY INSTR.

Scale Range
Output Range
Totalizer Typ
Compensatio
OPTIONS Preset Counte
Enclosure Cla
Strainer Size

Manufacturer ABB
FEW111025A1D3A1B1A1A0A1B3A1
Meter Model
Secondary Ins
NOTES:
SHEET __1__ OF__1__
SPEC. NO. REV.

CONTRACT DATE

REQ. P.O.

BY CHK'D APPR.

You might also like