Professional Documents
Culture Documents
1. IDENTIFICATION
Product name: Virex II 256 One-Step Disinfectant Cleaner and Deodorant; Quat Based Disinfectant
Product Code: 04329, 04331, 04332, 3062637, 3062768, 5019317, 5271416
SDS #: MS0801116
Recommended use: •Indust ri
al/
Inst
it
uti
onal
•Di si
nf ectant
•Thi spr oducti
sintendedt obedi l
utedpr iort
ouse
Uses advised against: Uses other than those identified are not recommended
2. HAZARDS IDENTIFICATION
Hazard Statements
CAUSES SEVERE SKIN BURNS AND SERIOUS EYE DAMAGE. HARMFUL IF SWALLOWED. MAY CAUSE DAMAGE TO ORGANS
THROUGH PROLONGED OR REPEATED EXPOSURE. MAY BE CORROSIVE TO METALS.
Precautionary Statements
Causes burns/ serious damage to mouth, throat and stomach. Keep container tightly closed. Keep only in original container. Avoid contact with
eyes, skin and clothing. Wash affected areas thoroughly after handling. Do not eat, drink or smoke when using this product. Wear protective gloves,
protective clothing and eye or face protection. IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical
personnel. Drink a cupful of milk or water. IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water for at least 15
minutes. Wash contaminated clothing before reuse. IF INHALED: Remove person to fresh air and keep comfortable for breathing. IF IN EYES:
Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least 15 minutes.
Immediately call a Poison Center (1-800-851-7145) or physician. Get medical attention or advice if you feel unwell. Absorb spillage to prevent
Virex II 256 One-Step Disinfectant 1 of 6
Cleaner and Deodorant; Quat Based
Disinfectant
material damage. Store in corrosive-resistant container with a resistant inner liner. Dispose of in accordance with all federal, state and local
applicable regulations. SUPPLEMENTAL INFORMATION:. Mix only with water. DO NOT MIX WITH BLEACH OR ANY OTHER PRODUCT OR
CHEMICAL. Can react to release chlorine gas.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Didecyl dimethyl ammonium chloride 7173-51-5 5 - 10%
n-alkyl dimethyl benzyl ammonium chloride 68424-85-1 5 - 10%
Ethyl alcohol 64-17-5 1 - 5%
Tetrasodium salt of EDTA 64-02-8 1 - 5%
Lauryl dimethyl amine oxide 1643-20-5 0.5 - 1.5%
Sodium sesquicarbonate 533-96-0 0.5 - 1.5%
1-decanamine, n-decyl-n-methyl- 7396-58-9 > 0.1 - < 1%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes.
Skin: IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water for at least 15 minutes.
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or
water.
Notes to physician: Probable mucosal damage may contraindicate the use of gastric lavage.
Diluted Product:
Eyes: Rinse with plenty of water.
Skin: No specific first aid measures are required
Inhalation: No specific first aid measures are required
Ingestion: IF SWALLOWED: Call a Poison Center (1-800-851-7145) or doctor/physician if you feel unwell.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Virex II 256 One-Step Disinfectant Cleaner and Deodorant; Quat Based Disinfectant 2 of 6
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Material is toxic to fish. Do not discharge into lakes, streams, ponds,
and clean-up methods: or public water unless in accordance with an NPDES permit. Prevent product from entering drains.
Water runoff can cause environmental damage. Soak up with inert absorbent material. Sweep up and
shovel into suitable containers for disposal. Use a water rinse for final clean-up.
Handling: Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Do not taste or swallow. Product residue may remain on/in
empty containers. All precautions for handling the product must be used in handling the empty container and residue. Avoid breathing vapors or
mists. Use only with adequate ventilation. Remove and wash contaminated clothing and footwear before re-use. Absorb spillage to prevent material
damage. Mix only with water. DO NOT MIX WITH BLEACH OR ANY OTHER PRODUCT OR CHEMICAL. Can react to release chlorine gas. FOR
COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Store in corrosive-resistant container with a resistant inner liner.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Diluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Virex II 256 One-Step Disinfectant Cleaner and Deodorant; Quat Based Disinfectant 3 of 6
Sustained combustion: The product does not sustain combustion
Explosion limits: - upper: Not determined - lower: Not determined
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Corrosive. Causes severe burns. Symptoms may include burns, blisters, redness and pain (which may be delayed).
Eye contact: Corrosive. Causes serious eye damage. Symptoms may include pain, burning sensation, redness, watering, blurred
vision or loss of vision.
Ingestion: Causes burns/ serious damage to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Harmful if swallowed. Symptoms may include vomiting, nausea, and/or feeling of general unwellness.
Inhalation: May cause irritation and corrosive effects to nose, throat and respiratory tract. Symptoms may include coughing and
difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): No information available
Virex II 256 One-Step Disinfectant Cleaner and Deodorant; Quat Based Disinfectant 4 of 6
Pesticide Storage:
Refer to product label.
Pesticide Disposal:
Refer to product label.
Container Disposal:
Refer to product label.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
DOT (Ground) Bill of Lading Description: UN1903, DISINFECTANTS, LIQUID, CORROSIVE, N.O.S., (quaternary ammonium compounds), 8, III
IMDG (Ocean) Bill of Lading Description: UN1903, DISINFECTANTS, LIQUID, CORROSIVE, N.O.S., (quaternary ammonium compounds), 8, III,
MARINE POLLUTANT
U.S. Regulations
EPA Reg. No. : 70627-24
This chemical is a pesticide product registered by the United States Environmental Protection Agency and is subject to certain labeling
requirements under federal pesticide law. These requirements differ from the classification criteria and hazard information required for safety data
sheets (SDS), and for workplace labels of non-pesticide chemicals. The hazard information required on the pesticide label is reproduced below. The
pesticide label also includes other important information, including directions for use.
DANGER: CORROSIVE. Causes irreversible eye damage and skin burns. Do not get in eyes, on skin or on clothing. Wear chemical splash-proof
goggles or face shield, rubber gloves and protective clothing. Harmful if swallowed, inhaled or absorbed through skin. Avoid breathing spray mist.
Wash thoroughly with soap and water after handling and before eating, drinking, chewing gum, using tobacco or using the toilet. Remove
contaminated clothing and wash before reuse.
CERCLA/ SARA
Canadian Regulations
Health 3
Flammability 2
Instability 0
Special Hazards -
Diluted Product:
Health 0
Flammability 0
Instability 0
Special Hazards -
Virex II 256 One-Step Disinfectant Cleaner and Deodorant; Quat Based Disinfectant 5 of 6
Revision: 2019-11-22
Version: 02.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Virex II 256 One-Step Disinfectant Cleaner and Deodorant; Quat Based Disinfectant 6 of 6
SAFETY DATA SHEET
Glance® NA
Glass & Multi-Surface Cleaner Non-Ammoniated
Revision: 2019-05-20 Version: 07.0
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
CAUSES SERIOUS EYE IRRITATION.
Precautionary Statements
Wash affected areas thoroughly after handling. Wear eye or face protection. IF IN EYES: Rinse cautiously with water for several minutes. Remove
contact lenses, if present and easy to do. Continue rinsing for at least 15 minutes. If eye irritation persists: Get medical advice or attention.
Glance® NA 1 of 5
Glass & Multi-Surface Cleaner
Non-Ammoniated
None required.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Alcohol ethoxylates 68439-46-3 1 - 5%
Sodium lauryl ether sulfate 9004-82-4 0.5 - 1.5%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes. If eye irritation persists: Get medical advice/attention.
Skin: No specific first aid measures are required.
Inhalation: No specific first aid measures are required.
Ingestion: IF SWALLOWED: Call a Poison Center (1-800-851-7145) or doctor/physician if you feel unwell.
Diluted Product:
Eyes: Rinse with plenty of water. If irritation occurs and persists, get medical attention.
Skin: No specific first aid measures are required
Inhalation: No specific first aid measures are required
Ingestion: IF SWALLOWED: Call a Poison Center (1-800-851-7145) or doctor/physician if you feel unwell.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with eyes. Wash thoroughly after handling. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: This product, as supplied, does not contain any hazardous materials with occupational exposure limits
established by the region specific regulatory bodies.
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Glance® NA 2 of 5
Glass & Multi-Surface Cleaner Non-Ammoniated
Personal Protective Equipment
Eye protection: Chemical-splash goggles.
Hand protection: Chemical-resistant gloves.
Skin and body protection: No personal protective equipment required under normal use conditions.
Respiratory protection: No personal protective equipment required under normal use conditions.
Hygiene measures: Handle in accordance with good industrial hygiene and safety practice.
Diluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Dilution pH: 7
Dilution Flash Point (°F): > 200 °F > 93.4 °C
VOC % by wt. at use dilution: 0.008%
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: May be mildly irritating to skin. Symptoms may include redness and/or transient discomfort.
Eye contact: Causes serious eye irritation. Symptoms may include pain, redness, and watering.
Ingestion: May be irritating to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May be irritating to nose, throat, and respiratory tract. Symptoms may include coughing and difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Glance® NA 3 of 5
Glass & Multi-Surface Cleaner Non-Ammoniated
Numerical measures of toxicity
ATE - Oral (mg/kg): >5000
ATE - Inhalatory, mists (mg/l): >20
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
Waste from residues / unused products (diluted product): This product, when diluted as stated on this SDS, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
CERCLA/ SARA
Canadian Regulations
Glance® NA 4 of 5
Glass & Multi-Surface Cleaner Non-Ammoniated
16. OTHER INFORMATION
NFPA (National Fire Protection Association)
Rating Scale: (Low Hazard) 0 - 4 (Extreme Hazard)
Health 2
Flammability 0
Instability 0
Special Hazards -
Diluted Product:
Health 0
Flammability 0
Instability 0
Special Hazards -
Revision: 2019-05-20
Version: 07.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Glance® NA 5 of 5
Glass & Multi-Surface Cleaner Non-Ammoniated
SAFETY DATA SHEET
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
HARMFUL IF SWALLOWED. CAUSES SKIN IRRITATION. CAUSES SERIOUS EYE DAMAGE.
Precautionary Statements
Causes burns/ serious damage to mouth, throat and stomach. Keep container tightly closed. Avoid contact with eyes, skin and clothing. Wash
affected areas thoroughly after handling. Do not eat, drink or smoke when using this product. Wear chemical-splash goggles and chemical-resistant
gloves. IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or water. IF
ON SKIN: Wash with plenty of soap and water. If skin irritation occurs: Get medical advice or attention. IF INHALED: Remove person to fresh air
and keep comfortable for breathing. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do.
Continue rinsing for at least 15 minutes. Immediately call a Poison Center (1-800-851-7145) or physician. Take off contaminated clothing and wash
it before reuse. Dispose of in accordance with all federal, state and local applicable regulations.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Potassium alkyl benzene sulfonate 85480-57-5 10 - 30%
Diethylene glycol monoethyl ether 111-90-0 3 - 7%
Benzyl alcohol 100-51-6 3 - 7%
Alcohol ethoxylate 68002-97-1 3 - 7%
Glycolic acid potassium salt 1932-50-9 1 - 5%
Citric acid 77-92-9 0.5 - 1.5%
Potassium Citrate 866-84-2 > 0.1 - < 1%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes.
Skin: IF ON SKIN: Wash with plenty of soap and water. If skin irritation occurs: Get medical advice/attention.
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or
water.
Diluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes. If eye irritation persists: Get medical advice/attention
Skin: No specific first aid measures are required
Inhalation: No specific first aid measures are required
Ingestion: IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Handling: Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Do not taste or swallow. Product residue may remain on/in
empty containers. All precautions for handling the product must be used in handling the empty container and residue. Avoid breathing vapors or
mists. Use only with adequate ventilation. Remove and wash contaminated clothing and footwear before re-use. FOR COMMERCIAL AND
INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: This product, as supplied, does not contain any hazardous materials with occupational exposure limits
established by the region specific regulatory bodies.
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Diluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Causes skin irritation. Symptoms may include pain (which may be delayed), redness, and/or discomfort.
Eye contact: Corrosive. Causes serious eye damage. Symptoms may include pain, burning sensation, redness, watering, blurred
vision or loss of vision.
Ingestion: Causes burns/ serious damage to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Harmful if swallowed. Symptoms may include vomiting, nausea, and/or feeling of general unwellness.
Inhalation: May cause irritation and corrosive effects to nose, throat and respiratory tract. Symptoms may include coughing and
difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
Waste from residues / unused products (diluted product): This product, when diluted as stated on this SDS, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Diethylene glycol monoethyl ether 111-90-0 3 - 7% X
Canadian Regulations
Health 3
Flammability 0
Instability 0
Special Hazards -
Diluted Product:
Health 2
Flammability 0
Instability 0
Special Hazards -
Revision: 2019-06-07
Version: 02.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Stride® Citrus HC
Neutral Cleaner
Revision: 2019-06-19 Version: 01.0
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
CAUSES SERIOUS EYE IRRITATION.
Precautionary Statements
Avoid contact with eyes, skin and clothing. Wash affected areas thoroughly after handling. May cause irritation to mouth, throat and stomach. Wear
chemical-splash goggles and chemical-resistant gloves. IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water. IF IN EYES: Rinse
cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least 15 minutes. If eye irritation
persists: Get medical advice or attention. Dispose of in accordance with all federal, state and local applicable regulations.
Stride® Citrus HC 1 of 5
Neutral Cleaner
Hazard and Precautionary Statements
None required.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Alcohol, C9-C11, ethoxylated 68439-46-3 10 - 30%
Sodium xylene sulfonate 1300-72-7 1 - 5%
fatty acids, coco, potassium salts 61789-30-8 1 - 5%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes. If eye irritation persists: Get medical advice/attention.
Skin: No specific first aid measures are required.
Inhalation: No specific first aid measures are required.
Ingestion: IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water.
Diluted Product:
Eyes: Rinse with plenty of water.
Skin: No specific first aid measures are required
Inhalation: No specific first aid measures are required
Ingestion: IF SWALLOWED: Call a Poison Center (1-800-851-7145) or doctor/physician if you feel unwell.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Do not taste or swallow. Product residue may remain on/in
empty containers. All precautions for handling the product must be used in handling the empty container and residue. Remove and wash
contaminated clothing and footwear before re-use. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: This product, as supplied, does not contain any hazardous materials with occupational exposure limits
established by the region specific regulatory bodies.
Stride® Citrus HC 2 of 5
Neutral Cleaner
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Diluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Unlikely to be irritant in normal use.
Eye contact: Causes serious eye irritation. Symptoms may include pain, redness, and watering.
Ingestion: May be irritating to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May be irritating to nose, throat, and respiratory tract. Symptoms may include coughing and difficulty breathing.
Stride® Citrus HC 3 of 5
Neutral Cleaner
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
Waste from residues / unused products (diluted product): This product, when diluted as stated on this SDS, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
CERCLA/ SARA
Stride® Citrus HC 4 of 5
Neutral Cleaner
Canadian Regulations
Health 2
Flammability 0
Instability 0
Special Hazards -
Diluted Product:
Health 0
Flammability 0
Instability 0
Special Hazards -
Revision: 2019-06-19
Version: 01.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Stride® Citrus HC 5 of 5
Neutral Cleaner
SAFETY DATA SHEET
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
CAUSES SKIN IRRITATION. CAUSES SERIOUS EYE DAMAGE. MAY BE CORROSIVE TO METALS.
Precautionary Statements
Causes burns/ serious damage to mouth, throat and stomach. Avoid contact with eyes, skin and clothing. Keep container tightly closed. Keep only
in original container. Wash affected areas thoroughly after handling. Wear chemical-splash goggles and chemical-resistant gloves. IF
SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or water. IF ON SKIN:
Wash with plenty of soap and water. If skin irritation occurs: Get medical advice or attention. IF INHALED: Remove person to fresh air and keep
comfortable for breathing. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue
rinsing for at least 15 minutes. Immediately call a Poison Center (1-800-851-7145) or physician. Take off contaminated clothing and wash it before
reuse. Absorb spillage to prevent material damage. Store in corrosive-resistant container with a resistant inner liner. Dispose of in accordance with
all federal, state and local applicable regulations. SUPPLEMENTAL INFORMATION:. Mix only with water. DO NOT MIX WITH AMMONIA,
BLEACH OR OTHER CHLORINATED COMPOUNDS. Can react to release hazardous gases. May vigorously react with strong alkaline products
resulting in spattering and excessive heat.
Classified Ingredients
Ingredient(s) CAS # Weight %
Urea hydrochloride 506-89-8 10 - 30%
Diethylene glycol butyl ether 112-34-5 1 - 5%
Ethoxylated oleyl amine 13127-82-7 0.5 - 1.5%
n-alkyl dimethyl benzyl ammonium chloride 68424-85-1 > 0.1 - < 1%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes.
Skin: IF ON SKIN: Wash with plenty of soap and water. If skin irritation occurs: Get medical advice/attention.
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or
water.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin, eyes and clothing. Do not taste or swallow. Avoid breathing vapors or mists. Use only with adequate ventilation.
Remove and wash contaminated clothing and footwear before re-use. Wash thoroughly after handling. Product residue may remain on/in empty
containers. All precautions for handling the product must be used in handling the empty container and residue. Corrosive to steel and aluminum.
Mix only with water. DO NOT MIX WITH AMMONIA, BLEACH, OR OTHER CHLORINATED COMPOUNDS. Can react to release hazardous gases.
May vigorously react with strong alkaline products resulting in spattering and excessive heat. Absorb spillage to prevent material damage. FOR
COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place. Store in corrosive-resistant container with a resistant inner liner.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Causes skin irritation. Symptoms may include pain (which may be delayed), redness, and/or discomfort.
Eye contact: Corrosive. Causes serious eye damage. Symptoms may include pain, burning sensation, redness, watering, blurred
vision or loss of vision.
Ingestion: Causes burns/ serious damage to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May cause irritation and corrosive effects to nose, throat and respiratory tract. Symptoms may include coughing and
difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Carcinogen Listings:
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is a hazardous waste according to
Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of disposal,
whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local laws and
regulations.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
DOT (Ground) Bill of Lading Description: UN3265, CORROSIVE LIQUID, ACIDIC, ORGANIC, N.O.S., (urea hydrochloride), 8, III
IMDG (Ocean) Bill of Lading Description: UN3265, CORROSIVE LIQUID, ACIDIC, ORGANIC, N.O.S., (urea hydrochloride), 8, III
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Diethylene glycol butyl ether 112-34-5 1 - 5% X
Canadian Regulations
Revision: 2019-06-07
Version: 03.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Classified Ingredients
Ingredient(s) CAS # Weight %
Quartz 14808-60-7 40 - 50%
Dodecylbenzene sulfonic acid 27176-87-0 10 - 20%
Alcohol ethoxylates 68439-46-3 10 - 20%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes.
Skin: IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water for at least 15 minutes.
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or
water.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: None.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Do not taste or swallow. Product residue may remain on/in
empty containers. All precautions for handling the product must be used in handling the empty container and residue. Avoid breathing vapors or
mists. Use only with adequate ventilation. Remove and wash contaminated clothing and footwear before re-use. Mix only with water. DO NOT MIX
WITH AMMONIA, BLEACH, OR OTHER CHLORINATED COMPOUNDS. Can react to release hazardous gases. May vigorously react with strong
alkaline products resulting in spattering and excessive heat. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Corrosive. Causes severe burns. Symptoms may include burns, blisters, redness and pain (which may be delayed).
Eye contact: Corrosive. Causes serious eye damage. Symptoms may include pain, burning sensation, redness, watering, blurred
vision or loss of vision.
Ingestion: Causes burns/ serious damage to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May cause irritation and corrosive effects to nose, throat and respiratory tract. Symptoms may include coughing and
difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Carcinogen Listings: This product contains Cristobalite/Quartz/Silica which is classified as a carcinogen. However, the
formulation is a heavy, viscous liquid and therefore there is no exposure to respirable-sized particles under normal use conditions
or foreseeable emergencies. This product contains a component that is classified by the International Agency for Research on
Cancer (IARC) as Group 1, "Carcinogenic to humans", which is generally based on sufficient evidence of carcinogenicity in
humans and sufficient evidence of carcinogenicity in experimental animals. No data is available on the product itself.
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is a hazardous waste according to
Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of disposal,
whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local laws and
regulations.
IMDG (Ocean) Bill of Lading Description: UN3265, CORROSIVE LIQUID, ACIDIC, ORGANIC, N.O.S., (dodecylbenzene sulfonic acid), 8, III,
LTD. QTY.
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Dodecylbenzene sulfonic acid 27176-87-0 10 - 20% 1000
Canadian Regulations
Health 3
Flammability 0
Instability 0
Special Hazards -
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
None required.
Precautionary Statements
None required.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Sodium lauryl sulfate 68585-47-7 > 0.1 - < 1%
Undiluted Product:
Eyes: Rinse with plenty of water. If irritation occurs and persists, get medical attention.
Skin: No specific first aid measures are required.
Inhalation: No specific first aid measures are required.
Glance RTU Glass & Multi-Surface 1 of 4
Cleaner
Ingestion: Rinse mouth with water.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Handle in accordance with good industrial hygiene and safety practice. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: This product, as supplied, does not contain any hazardous materials with occupational exposure limits
established by the region specific regulatory bodies.
Undiluted Product:
Engineering measures to reduce exposure:
No special ventilation requirements.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Unlikely to be irritant in normal use.
Eye contact: May be mildly irritating to eyes.
Ingestion: No information available.
Inhalation: No information available.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Diethylene glycol butyl ether 112-34-5 > 0.1 - < 1% X
2-butoxyethanol 111-76-2 > 0.1 - < 1% X
Canadian Regulations
Health 0
Flammability 0
Instability 0
Special Hazards -
Revision: 2019-03-08
Version: 02.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
EXTREMELY FLAMMABLE AEROSOL. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
Precautionary Statements
Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking. Do not spray on an open flame or other ignition
source. Do not pierce or burn, even after use. Do not incinerate. Protect from sunlight. Store in a well-ventilated place. Do not expose to
temperatures exceeding 50 °C (122 °F) which may cause bursting. Dispose of in accordance with all federal, state and local applicable regulations.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Butane 106-97-8 1 - 5%
Ethyl alcohol 64-17-5 1 - 5%
Propane 74-98-6 0.5 - 1.5%
Ammonia 7664-41-7 > 0.1 - < 1%
Undiluted Product:
Eyes: Rinse with plenty of water. If irritation occurs and persists, get medical attention.
Skin: No specific first aid measures are required.
Inhalation: No specific first aid measures are required.
Ingestion: Rinse mouth with water.
Diluted Product:
This product is intended to be used neat.
Eyes: Rinse with plenty of water.
Skin: No specific first aid measures are required
Inhalation: No specific first aid measures are required
Ingestion: IF SWALLOWED: Call a Poison Center (1-800-851-7145) or doctor/physician if you feel unwell.
5. FIRE-FIGHTING MEASURES
Specific methods: Aerosol Product - Containers may rocket or explode in heat of fire Use water spray to keep
fire-exposed containers cool
Suitable extinguishing media: Use dry chemical, CO2, water spray or "alcohol" foam.
Specific hazards: Aerosol product - Containers may rocket or explode in heat of fire. NFPA 30B Level 3 Aerosol.
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.). Remove all sources of ignition.
Contents under pressure. Do not puncture or incinerate cans.
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up. Eliminate all ignition sources.
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
No special ventilation requirements. General room ventilation is adequate.
Eye protection: No personal protective equipment required under normal use conditions.
Hand protection: No personal protective equipment required under normal use conditions.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: May be mildly irritating to skin. Symptoms may include redness and/or transient discomfort.
Eye contact: May be mildly irritating to eyes.
Ingestion: No information available.
Inhalation: No information available.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Waste from residues / unused products (undiluted product): Use up contents if possible before disposal. If possible, recycle empty aerosol
cans to the nearest steel recycling center. This product, as sold, if discarded or disposed, is a hazardous waste according to Federal regulations (40
CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of disposal, whether the waste solution
meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local laws and regulations.
Waste from residues / unused products (diluted product): This product, when diluted as stated on this SDS, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
IMDG (Ocean) Bill of Lading Description: UN1950, AEROSOLS, 2.1, LTD. QTY.
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Ammonia 7664-41-7 > 0.1 - < 1% 100 100 X
Canadian Regulations
Revision: 2019-11-26
Version: 01.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Oxivir Tb (US)
General Virucide, Bactericide, Tuberculocide, Fungicide, Sanitizer
Revision: 2019-04-26 Version: 03.0
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
None required.
Precautionary Statements
None required.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Benzyl alcohol 100-51-6 1 - 5%
Hydrogen peroxide 7722-84-1 > 0.1 - < 1%
Dodecylbenzene sulfonic acid 68584-22-5 > 0.1 - < 1%
Oxivir Tb (US) 1 of 4
General Virucide, Bactericide,
Tuberculocide, Fungicide, Sanitizer
4. FIRST AID MEASURES
Undiluted Product:
Eyes: Rinse with plenty of water. If irritation occurs and persists, get medical attention.
Skin: No specific first aid measures are required.
Inhalation: No specific first aid measures are required.
Ingestion: Rinse mouth with water.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin and eyes. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Oxivir Tb (US) 2 of 4
General Virucide, Bactericide, Tuberculocide, Fungicide, Sanitizer
Bulk density: No information available Vapor pressure: No information available.
Flash point (°F): >200°F > 93 °C Partition coefficient (n-octanol/water): No information available
Viscosity: 1 No information available Elemental Phosphorus: 0.12 % by wt.
VOC: 0 % * pH: 3
Flammability (Solid or Gas): Not applicable Corrosion to metals: Not corrosive to metals
Sustained combustion: Not applicable
Explosion limits: - upper: Not determined - lower: Not determined
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Unlikely to be irritant in normal use.
Eye contact: May be mildly irritating to eyes.
Ingestion: No information available.
Inhalation: No information available.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Pesticide Storage:
Refer to product label.
Oxivir Tb (US) 3 of 4
General Virucide, Bactericide, Tuberculocide, Fungicide, Sanitizer
Pesticide Disposal:
Refer to product label.
Container Disposal:
Refer to product label.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
U.S. Regulations
EPA Reg. No. : 70627-56
This chemical is a pesticide product registered by the United States Environmental Protection Agency and is subject to certain labeling
requirements under federal pesticide law. These requirements differ from the classification criteria and hazard information required for safety data
sheets (SDS), and for workplace labels of non-pesticide chemicals. The hazard information required on the pesticide label is reproduced below. The
pesticide label also includes other important information, including directions for use.
ENVIRONMENTAL HAZARDS: This product is toxic to birds, fish and aquatic invertebrates. Caution should be used when applying indoors
because pets may be at risk.
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Hydrogen peroxide 7722-84-1 > 0.1 - < 1% 1000
Canadian Regulations
Health 0
Flammability 0
Instability 0
Special Hazards -
Revision: 2019-04-26
Version: 03.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Oxivir Tb (US) 4 of 4
General Virucide, Bactericide, Tuberculocide, Fungicide, Sanitizer
SAFETY DATA SHEET
Extraction Rinse
Revision: 2019-05-22 Version: 01.0
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
CAUSES SKIN AND SERIOUS EYE IRRITATION.
Precautionary Statements
Avoid contact with eyes, skin and clothing. Wash affected areas thoroughly after handling. May cause irritation to mouth, throat and stomach. Wear
chemical-splash goggles and chemical-resistant gloves. IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water. IF ON SKIN: Wash with
plenty of soap and water. If skin irritation occurs: Get medical advice or attention. IF IN EYES: Rinse cautiously with water for several minutes.
Remove contact lenses, if present and easy to do. Continue rinsing for at least 15 minutes. If eye irritation persists: Get medical advice or attention.
Take off contaminated clothing and wash it before reuse. Dispose of in accordance with all federal, state and local applicable regulations.
Extraction Rinse 1 of 5
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Sodium xylene sulfonate 1300-72-7 1 - 5%
Hydroxyacetic acid 79-14-1 1 - 5%
Linear alcohol alkoxylate 68987-81-5 > 0.1 - < 1%
Alcohol ethoxylates 68439-46-3 > 0.1 - < 1%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes. If eye irritation persists: Get medical advice/attention.
Skin: IF ON SKIN: Wash with plenty of soap and water. If skin irritation occurs: Get medical advice/attention.
Inhalation: No specific first aid measures are required.
Ingestion: IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water.
Diluted Product:
Eyes: Rinse with plenty of water.
Skin: No specific first aid measures are required
Inhalation: No specific first aid measures are required
Ingestion: IF SWALLOWED: Call a Poison Center (1-800-851-7145) or doctor/physician if you feel unwell.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin and eyes. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: This product, as supplied, does not contain any hazardous materials with occupational exposure limits
established by the region specific regulatory bodies.
Undiluted Product:
Engineering measures to reduce exposure:
No special ventilation requirements. General room ventilation is adequate.
Extraction Rinse 2 of 5
Personal Protective Equipment
Eye protection: Chemical-splash goggles.
Hand protection: Chemical-resistant gloves.
Skin and body protection: No personal protective equipment required under normal use conditions.
Respiratory protection: No personal protective equipment required under normal use conditions.
Hygiene measures: Handle in accordance with good industrial hygiene and safety practice.
Diluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Causes skin irritation. Symptoms may include pain (which may be delayed), redness, and/or discomfort.
Eye contact: Causes serious eye irritation. Symptoms may include pain, redness, and watering.
Ingestion: May be irritating to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May be irritating to nose, throat, and respiratory tract. Symptoms may include coughing and difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Extraction Rinse 3 of 5
Numerical measures of toxicity
ATE - Oral (mg/kg): >5000
ATE - Inhalatory, vapors (mg/l): 440
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
Waste from residues / unused products (diluted product): This product, when diluted as stated on this SDS, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
CERCLA/ SARA
Canadian Regulations
Extraction Rinse 4 of 5
16. OTHER INFORMATION
NFPA (National Fire Protection Association)
Rating Scale: (Low Hazard) 0 - 4 (Extreme Hazard)
Health 2
Flammability 0
Instability 0
Special Hazards -
Diluted Product:
Health 0
Flammability 0
Instability 0
Special Hazards -
Revision: 2019-05-22
Version: 01.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Extraction Rinse 5 of 5
SAFETY DATA SHEET
Defoamer
Revision: 2019-08-02 Version: 01.0
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
None required.
Precautionary Statements
None required.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Methanol 67-56-1 > 0.1 - < 1%
Undiluted Product:
Eyes: Rinse with plenty of water. If irritation occurs and persists, get medical attention.
Skin: No specific first aid measures are required.
Inhalation: No specific first aid measures are required.
Defoamer 1 of 4
Ingestion: Rinse mouth with water.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin and eyes. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Defoamer 2 of 4
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Unlikely to be irritant in normal use.
Eye contact: May be mildly irritating to eyes.
Ingestion: No information available.
Inhalation: No information available.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
Defoamer 3 of 4
IMDG (Ocean) Bill of Lading Description: NOT REGULATED
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Methanol 67-56-1 > 0.1 - < 1% 5000 X
Canadian Regulations
Health 0
Flammability 0
Instability 0
Special Hazards -
Revision: 2019-08-02
Version: 01.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Defoamer 4 of 4
SAFETY DATA SHEET
Carpet Shampoo
Revision: 2018-12-19 Version: 01.0
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
CAUSES SERIOUS EYE DAMAGE.
Precautionary Statements
Causes burns/ serious damage to mouth, throat and stomach. Keep container tightly closed. Avoid contact with eyes, skin and clothing. Wash
affected areas thoroughly after handling. Wear chemical-splash goggles and chemical-resistant gloves. IF SWALLOWED: Rinse mouth. DO NOT
induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or water. IF INHALED: Remove person to fresh air and keep
comfortable for breathing. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue
rinsing for at least 15 minutes. Immediately call a Poison Center (1-800-851-7145) or physician. Dispose of in accordance with all federal, state and
local applicable regulations.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Sodium lauryl sulfate 151-21-3 5 - 10%
Ammonium hydroxide 1336-21-6 > 0.1 - < 1%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes.
Skin: Rinse with plenty of water.
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or
water.
Diluted Product:
Eyes: Rinse with plenty of water.
Skin: No specific first aid measures are required
Inhalation: No specific first aid measures are required
Ingestion: IF SWALLOWED: Call a Poison Center (1-800-851-7145) or doctor/physician if you feel unwell.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Do not taste or swallow. Product residue may remain on/in
empty containers. All precautions for handling the product must be used in handling the empty container and residue. Avoid breathing vapors or
mists. Use only with adequate ventilation. Remove and wash contaminated clothing and footwear before re-use. FOR COMMERCIAL AND
INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: This product, as supplied, does not contain any hazardous materials with occupational exposure limits
established by the region specific regulatory bodies.
Undiluted Product:
Carpet Shampoo 2 of 5
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Diluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: May be mildly irritating to skin. Symptoms may include redness and/or transient discomfort.
Eye contact: Corrosive. Causes serious eye damage. Symptoms may include pain, burning sensation, redness, watering, blurred
vision or loss of vision.
Ingestion: Causes burns/ serious damage to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May cause irritation and corrosive effects to nose, throat and respiratory tract. Symptoms may include coughing and
difficulty breathing.
Carpet Shampoo 3 of 5
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
Waste from residues / unused products (diluted product): This product, when diluted as stated on this SDS, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Ammonium hydroxide 1336-21-6 > 0.1 - < 1% 1000 100 X
Carpet Shampoo 4 of 5
Canadian Regulations
Health 3
Flammability 0
Instability 0
Special Hazards -
Diluted Product:
Health 0
Flammability 0
Instability 0
Special Hazards -
Revision: 2018-12-19
Version: 01.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Carpet Shampoo 5 of 5
SAFETY DATA SHEET
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
COMBUSTIBLE LIQUID. MAY CAUSE DROWSINESS OR DIZZINESS.
Precautionary Statements
Keep away from flames and hot surfaces. No smoking. Avoid breathing vapors. Wash affected areas thoroughly after handling. Use only in a
well-ventilated area. IF INHALED: Remove person to fresh air and keep comfortable for breathing. Call a Poison Center (1-800-851-7145) or
physician if you feel unwell. Store in a well-ventilated place. Keep cool. Dispose of in accordance with all federal, state and local applicable
regulations.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Undiluted Product:
Eyes: Rinse with plenty of water. If irritation occurs and persists, get medical attention.
Skin: No specific first aid measures are required.
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: Rinse mouth with water.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Material is toxic to fish. Do not discharge into lakes, streams, ponds,
and clean-up methods: or public water unless in accordance with an NPDES permit. Prevent product from entering drains.
Water runoff can cause environmental damage. Soak up with inert absorbent material. Sweep up and
shovel into suitable containers for disposal. Use a water rinse for final clean-up.
Handling: COMBUSTIBLE LIQUID. Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking. Keep
container tightly closed. Ground/Bond container and receiving equipment. Use explosion-proof electrical, ventilating or lighting equipment. Use only
non-sparking tools. Take precautionary measures against static discharge. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Store in a well-ventilated place. Keep cool. Store locked up.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Eye protection: No personal protective equipment required under normal use conditions.
Hand protection: No personal protective equipment required under normal use conditions.
Skin and body protection: No personal protective equipment required under normal use conditions.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Unlikely to be irritant in normal use.
Eye contact: May be mildly irritating to eyes.
Ingestion: No information available.
Inhalation: No information available.
Sensitization: No known effects.
Target Organs (SE): No information available
Target Organs (RE): None known
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Diethylene glycol butyl ether 112-34-5 10 - 30% X
Canadian Regulations
Health 0
Flammability 2
Instability 0
Special Hazards -
Revision: 2019-11-20
Version: 03.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
CAUSES SERIOUS EYE IRRITATION.
Precautionary Statements
Avoid contact with eyes, skin and clothing. Wash affected areas thoroughly after handling. May cause irritation to mouth, throat and stomach. Wear
chemical-splash goggles and chemical-resistant gloves. IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water. IF IN EYES: Rinse
cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least 15 minutes. If eye irritation
persists: Get medical advice or attention. Dispose of in accordance with all federal, state and local applicable regulations.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
General Purpose Spotter 1 of 4
with Percolator Technology
Ingredient(s) CAS # Weight %
Hydrogen peroxide 7722-84-1 1 - 5%
Sodium alpha olefin sulfonate 68439-57-6 0.5 - 1.5%
Alcohol ethoxylates 68439-46-3 > 0.1 - < 1%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes. If eye irritation persists: Get medical advice/attention.
Skin: No specific first aid measures are required.
Inhalation: No specific first aid measures are required.
Ingestion: IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Do not taste or swallow. Product residue may remain on/in
empty containers. All precautions for handling the product must be used in handling the empty container and residue. Remove and wash
contaminated clothing and footwear before re-use. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Unlikely to be irritant in normal use.
Eye contact: Causes serious eye irritation. Symptoms may include pain, redness, and watering.
Ingestion: May be irritating to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May be irritating to nose, throat, and respiratory tract. Symptoms may include coughing and difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Hydrogen peroxide 7722-84-1 1 - 5% 1000
Canadian Regulations
Health 2
Flammability 0
Instability 0
Special Hazards -
Revision: 2019-03-27
Version: 01.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Gum Remover
Revision: 2019-10-07 Version: 02.0
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
EXTREMELY FLAMMABLE GAS. HIGHLY FLAMMABLE LIQUID AND VAPOR. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF
HEATED. CAUSES EYE IRRITATION.
Precautionary Statements
Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking. Keep container tightly closed. Ground/Bond
container and receiving equipment. Use explosion-proof electrical, ventilating or lighting equipment. Use only non-sparking tools. Take
precautionary measures against static discharge. Avoid contact with eyes, skin and clothing. Wash affected areas thoroughly after handling. IF ON
SKIN (or hair): Take off immediately all contaminated clothing. Wash contaminated clothing before reuse. IF IN EYES: Rinse cautiously with water
for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least 15 minutes. If eye irritation persists: Get medical
advice or attention. Rinse skin with water for at least 15 minutes. Leaking gas fire: do not extinguish, unless leak can be stopped safely. Eliminate
all ignition sources if safe to do so. Store in a well-ventilated place. Keep cool. Protect from sunlight. Store in a well-ventilated place. Dispose of in
accordance with all federal, state and local applicable regulations.
Gum Remover 1 of 5
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Butane 106-97-8 40 - 70%
Propane 74-98-6 10 - 30%
Ethyl alcohol 64-17-5 7 - 13%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes. If eye irritation persists: Get medical advice/attention.
Skin: IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water for at least 15 minutes.
Inhalation: No specific first aid measures are required.
Ingestion: Rinse mouth with water.
5. FIRE-FIGHTING MEASURES
Specific methods: Aerosol Product - Containers may rocket or explode in heat of fire
Suitable extinguishing media: Use dry chemical, CO2, water spray or "alcohol" foam.
Specific hazards: Keep product and empty container away from heat and sources of ignition.
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: HIGHLY FLAMMABLE LIQUID AND VAPOR. Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No
smoking. Keep container tightly closed. Ground/Bond container and receiving equipment. Use explosion-proof electrical, ventilating or lighting
equipment. Use only non-sparking tools. Take precautionary measures against static discharge. Wash thoroughly after handling. Avoid prolonged
or repeated contact with skin. Avoid contact with eyes.
Storage: Store in a well-ventilated place. Keep cool. Store locked up.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
No special ventilation requirements. General room ventilation is adequate.
Gum Remover 2 of 5
Personal Protective Equipment
Eye protection: No personal protective equipment required under normal use conditions.
Hand protection: No personal protective equipment required under normal use conditions.
Skin and body protection: No personal protective equipment required under normal use conditions.
Respiratory protection: No personal protective equipment required under normal use conditions.
Hygiene measures: Handle in accordance with good industrial hygiene and safety practice.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Unlikely to be irritant in normal use.
Eye contact: Causes eye irritation. Symptoms may include discomfort, redness, and watering.
Ingestion: May be irritating to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May be irritating to nose, throat, and respiratory tract. Symptoms may include coughing and difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Carcinogen Listings: Ethyl alcohol is only classified as an IARC 1 carcinogen and California Prop 65 chemical when it is meant
for ingestion in alcoholic beverages. We do not produce alcoholic beverages; therefore it is not considered a carcinogen in our
products.
Gum Remover 3 of 5
Persistence and Degradability: No information available.
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is a hazardous waste according to
Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of disposal,
whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local laws and
regulations.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
CERCLA/ SARA
Canadian Regulations
Health 1
Flammability 4
Instability 0
Special Hazards -
Revision: 2019-10-07
Version: 02.0
Gum Remover 4 of 5
Additional advice: •Cont
ainsanaddedf
ragr
ance,see"
Odor
"headi
ngi
nsect
ion9f
orspeci
fi
cdescr
ipt
ion
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Gum Remover 5 of 5
SAFETY DATA SHEET
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
CAUSES SEVERE SKIN BURNS AND SERIOUS EYE DAMAGE. MAY CAUSE RESPIRATORY IRRITATION. MAY BE CORROSIVE TO
METALS.
Precautionary Statements
Causes burns/ serious damage to mouth, throat and stomach. Keep only in original container. Do not breathe vapors. Avoid contact with eyes, skin
and clothing. Wash affected areas thoroughly after handling. Use only in a well-ventilated area. Wear protective gloves, protective clothing and eye
or face protection. IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk
or water. IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water for at least 15 minutes. Wash contaminated
clothing before reuse. IF INHALED: Remove person to fresh air and keep comfortable for breathing. IF IN EYES: Rinse cautiously with water for
several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least 15 minutes. Immediately call a Poison Center
(1-800-851-7145) or physician. Absorb spillage to prevent material damage. Store in a well-ventilated place. Keep container tightly closed. Store in
corrosive-resistant container with a resistant inner liner. Dispose of in accordance with all federal, state and local applicable regulations.
SUPPLEMENTAL INFORMATION:. DO NOT MIX WITH AMMONIA, BLEACH OR OTHER CHLORINATED COMPOUNDS. Mix only with water.
Can react to release hazardous gases. May vigorously react with strong alkaline products resulting in spattering and excessive heat.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Monoethanolamine 141-43-5 7 - 13%
Benzyl alcohol 100-51-6 5 - 10%
Diethylene glycol monoethyl ether 111-90-0 1 - 5%
Sodium hydroxide 1310-73-2 1 - 5%
Sodium xylene sulfonate 1300-72-7 1 - 5%
Hexyloxyethanol 112-25-4 > 0.1 - < 1%
Benzene, 1,1`-oxybis-, tetrapropylene derivs., 119345-04-9 > 0.1 - < 1%
sulfonated, sodium salts
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes.
Skin: IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water for at least 15 minutes.
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or
water.
Diluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes.
Skin: IF ON SKIN: Wash with plenty of soap and water If skin irritation occurs: Get medical advice/attention
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or
water.
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Do not taste or swallow. Product residue may remain on/in
empty containers. All precautions for handling the product must be used in handling the empty container and residue. Avoid breathing vapors or
mists. Use only with adequate ventilation. Remove and wash contaminated clothing and footwear before re-use. Can react to release hazardous
gases. Mix only with water. Do not mix with any other product or chemical. May vigorously react with acids resulting in spattering and excessive
heat.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels. Respiratory protection is not required if good ventilation is maintained.
Diluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Dilution pH: 13
Dilution Flash Point (°F): > 200 °F > 93.4 °C
VOC % by wt. at use dilution: 2
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Corrosive. Causes severe burns. Symptoms may include burns, blisters, redness and pain (which may be delayed).
Eye contact: Corrosive. Causes serious eye damage. Symptoms may include pain, burning sensation, redness, watering, blurred
vision or loss of vision.
Ingestion: Causes burns/ serious damage to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May cause irritation and corrosive effects to nose, throat and respiratory tract. Symptoms may include coughing and
difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): No information available
Target Organs (RE): None known
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is a hazardous waste according to
DOT (Ground) Bill of Lading Description: UN3267, CORROSIVE LIQUID, BASIC, ORGANIC, N.O.S., (ethanolamine, sodium hydroxide), 8, III
IMDG (Ocean) Bill of Lading Description: UN3267, CORROSIVE LIQUID, BASIC, ORGANIC, N.O.S., (ethanolamine, sodium hydroxide), 8, III
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Diethylene glycol monoethyl ether 111-90-0 1 - 5% X
Sodium hydroxide 1310-73-2 1 - 5% 1000
Hexyloxyethanol 112-25-4 > 0.1 - < 1% X
Canadian Regulations
Health 3
Flammability 0
Instability 0
Special Hazards -
Diluted Product:
Health 3
Flammability 0
Instability 0
Special Hazards -
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Sodium hydroxide 1310-73-2 5 - 10%
Monoethanolamine 141-43-5 3 - < 5%
Sodium chlorite 7758-19-2 < 0.1%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes.
Skin: IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water for at least 15 minutes.
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or
water.
Diluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes. If eye irritation persists: Get medical advice/attention
Skin: IF ON SKIN: Wash with plenty of soap and water If skin irritation occurs: Get medical advice/attention
Inhalation: No specific first aid measures are required
Ingestion: IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Do not taste or swallow. Product residue may remain on/in
empty containers. All precautions for handling the product must be used in handling the empty container and residue. Avoid breathing vapors or
mists. Use only with adequate ventilation. Remove and wash contaminated clothing and footwear before re-use. Wash thoroughly after handling.
Mix only with water. Do not mix with any other product or chemical. Can react to release hazardous gases. May vigorously react with acids resulting
in spattering and excessive heat. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Protect from freezing. Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
Use only in well-ventilated areas. Good general ventilation should be sufficient to control airborne levels. Respiratory protection is not required if
good ventilation is maintained.
Diluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Corrosive. Causes severe burns. Symptoms may include burns, blisters, redness and pain (which may be delayed).
Eye contact: Corrosive. Causes serious eye damage. Symptoms may include pain, burning sensation, redness, watering, blurred
vision or loss of vision.
Ingestion: Causes burns/ serious damage to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May cause irritation and corrosive effects to nose, throat and respiratory tract. Symptoms may include coughing and
difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Carcinogen Listings: Ethyl alcohol is only classified as an IARC 1 carcinogen and California Prop 65 chemical when it is meant
for ingestion in alcoholic beverages. We do not produce alcoholic beverages; therefore it is not considered a carcinogen in our
products.
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is a hazardous waste according to
Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of disposal,
whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local laws and
regulations.
Waste from residues / unused products (diluted product): This product, when diluted as stated on this SDS, is a hazardous waste according to
DOT (Ground) Bill of Lading Description: UN3266, CORROSIVE LIQUID, BASIC, INORGANIC, N.O.S., (sodium hydroxide, ethanolamine), 8, II
IMDG (Ocean) Bill of Lading Description: UN3266, CORROSIVE LIQUID, BASIC, INORGANIC, N.O.S., (sodium hydroxide, ethanolamine), 8, II
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Sodium hydroxide 1310-73-2 5 - 10% 1000
Canadian Regulations
Health 3
Flammability 0
Instability 0
Diluted Product:
Health 2
Flammability 0
Instability 0
Version Number: 2
Preparation date: 2015-09-15
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
1. IDENTIFICATION
Product name: Power-Foam Bravo Heavy Duty Stripper for Spot Buildups
Product Code: 94966769
SDS #: MS0800173
Recommended use: •Industri
al/
Instit
ut i
onal
•Floorstri
pper
•Thispr oductisi ntendedt obeusedneat .
Uses advised against: Uses other than those identified are not recommended
2. HAZARDS IDENTIFICATION
Hazard Statements
EXTREMELY FLAMMABLE GAS. COMBUSTIBLE LIQUID. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED. CAUSES
SEVERE SKIN BURNS AND SERIOUS EYE DAMAGE. MAY BE CORROSIVE TO METALS.
Precautionary Statements
Causes burns/ serious damage to mouth, throat and stomach. Keep away from heat, hot surfaces, sparks, open flames and other ignition sources.
No smoking. Keep away from flames and hot surfaces. No smoking. Keep container tightly closed. Keep only in original container. Do not breathe
spray. Avoid contact with eyes, skin and clothing. Wash affected areas thoroughly after handling. Wear chemical-splash goggles, long
chemical-resistant gloves, protective clothing and protective footwear when spraying and wiping. Do not spray towards face. IF SWALLOWED:
Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or water. IF ON SKIN (or hair): Take
off immediately all contaminated clothing. Rinse skin with water for at least 15 minutes. Wash contaminated clothing before reuse. IF INHALED:
Remove person to fresh air and keep comfortable for breathing. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact
lenses, if present and easy to do. Continue rinsing for at least 15 minutes. Immediately call a Poison Center (1-800-851-7145) or physician. In case
of fire: Use CO2, dry chemical, or foam to extinguish. Leaking gas fire: do not extinguish, unless leak can be stopped safely. Eliminate all ignition
sources if safe to do so. Absorb spillage to prevent material damage. Store in a well-ventilated place. Keep cool. Store in corrosive-resistant
container with a resistant inner liner. Protect from sunlight. Store in a well-ventilated place. Dispose of in accordance with all federal, state and local
applicable regulations. SUPPLEMENTAL INFORMATION:. DO NOT MIX WITH AMMONIA, BLEACH OR OTHER CHLORINATED COMPOUNDS.
Power-Foam Bravo Heavy Duty Stripper 1 of 5
for Spot Buildups
Mix only with water. Can react to release hazardous gases. May vigorously react with strong alkaline products resulting in spattering and excessive
heat.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Isobutane 75-28-5 3 - 7%
Potassium hydroxide 1310-58-3 1 - 5%
Diethylene glycol butyl ether 112-34-5 1 - 5%
Alcohol ethoxylates 68131-39-5 1 - 5%
2-butoxyethanol 111-76-2 1 - 5%
Monoethanolamine 141-43-5 1 - 5%
Benzyl alcohol 100-51-6 0.5 - 1.5%
Organic phosphate ester 68130-47-2 > 0.1 - < 1%
Sodium metasilicate 6834-92-0 > 0.1 - < 1%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes.
Skin: IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water for at least 15 minutes.
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or
water.
5. FIRE-FIGHTING MEASURES
Specific methods: Aerosol Product - Containers may rocket or explode in heat of fire Use water spray to keep
fire-exposed containers cool
Suitable extinguishing media: Use dry chemical, CO2, water spray or "alcohol" foam.
Specific hazards: Corrosive material (See sections 8 and 10).
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Mix only with water. DO NOT MIX WITH AMMONIA, BLEACH, OR OTHER CHLORINATED COMPOUNDS. May vigorously react with
strong alkaline products resulting in spattering and excessive heat. Can react to release hazardous gases. COMBUSTIBLE LIQUID. Keep away
from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking. Keep container tightly closed. Avoid contact with skin, eyes
and clothing. Wash thoroughly after handling. Do not taste or swallow. Product residue may remain on/in empty containers. All precautions for
handling the product must be used in handling the empty container and residue. Avoid breathing vapors or mists. Use only with adequate
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Corrosive. Causes severe burns. Symptoms may include burns, blisters, redness and pain (which may be delayed).
Eye contact: Corrosive. Causes serious eye damage. Symptoms may include pain, burning sensation, redness, watering, blurred
vision or loss of vision.
Ingestion: Causes burns/ serious damage to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May cause irritation and corrosive effects to nose, throat and respiratory tract. Symptoms may include coughing and
difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is a hazardous waste according to
Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of disposal,
whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local laws and
regulations.
RCRA Hazard Class (undiluted product): D001 Ignitable Waste D002 Corrosive Waste
Contaminated Packaging: Do not re-use empty containers.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Potassium hydroxide 1310-58-3 1 - 5% 1000
Diethylene glycol butyl ether 112-34-5 1 - 5% X
2-butoxyethanol 111-76-2 1 - 5% X
Canadian Regulations
Health 3
Flammability 4
Instability 0
Special Hazards -
Revision: 2019-04-30
Version: 02.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Easy Paks
Neutralizer Conditioner / Odor Counteractant
Revision: 2019-05-13 Version: 03.0
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
CAUSES SERIOUS EYE IRRITATION.
Precautionary Statements
If medical advice is needed, have product container or label at hand. Keep out of reach of children. Avoid contact with eyes, skin and clothing.
Wash affected areas thoroughly after handling. May cause irritation to mouth, throat and stomach. Wear chemical-splash goggles and
chemical-resistant gloves. IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water. IF IN EYES: Rinse cautiously with water for several
minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least 15 minutes. If eye irritation persists: Get medical advice or
attention. Dispose of in accordance with all federal, state and local applicable regulations.
Easy Paks 1 of 5
Neutralizer Conditioner / Odor
Counteractant
Canadian Hazardous Products Regulations (HPR) (WHMIS 2015-GHS).
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Citric acid 77-92-9 60 - 100%
Sodium carbonate 497-19-8 10 - 30%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes. If eye irritation persists: Get medical advice/attention.
Skin: No specific first aid measures are required.
Inhalation: No specific first aid measures are required.
Ingestion: IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water.
Diluted Product:
Eyes: Rinse with plenty of water.
Skin: No specific first aid measures are required
Inhalation: No specific first aid measures are required
Ingestion: IF SWALLOWED: Call a Poison Center (1-800-851-7145) or doctor/physician if you feel unwell.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Do not taste or swallow. Product residue may remain on/in
empty containers. All precautions for handling the product must be used in handling the empty container and residue. Remove and wash
contaminated clothing and footwear before re-use. Avoid breaking packets. Do not handle with wet hands or cut/puncture packets. If packets stick
together, do not try to separate them. Keep out of reach of children. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: This product, as supplied, does not contain any hazardous materials with occupational exposure limits
established by the region specific regulatory bodies.
Easy Paks 2 of 5
Neutralizer Conditioner / Odor Counteractant
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Diluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Unlikely to be irritant in normal use.
Eye contact: Causes serious eye irritation. Symptoms may include pain, redness, and watering.
Easy Paks 3 of 5
Neutralizer Conditioner / Odor Counteractant
Ingestion: May be irritating to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May be irritating to nose, throat, and respiratory tract. Symptoms may include coughing and difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
Waste from residues / unused products (diluted product): This product, when diluted as stated on this SDS, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
CERCLA/ SARA
Easy Paks 4 of 5
Neutralizer Conditioner / Odor Counteractant
Canadian Regulations
Health 2
Flammability 0
Instability 0
Special Hazards -
Diluted Product:
Health 0
Flammability 0
Instability 0
Special Hazards -
Revision: 2019-05-13
Version: 03.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Easy Paks 5 of 5
Neutralizer Conditioner / Odor Counteractant
SAFETY DATA SHEET
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
CAUSES EYE IRRITATION.
Precautionary Statements
Avoid contact with eyes, skin and clothing. Wash affected areas thoroughly after handling. IF IN EYES: Rinse cautiously with water for several
minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least 15 minutes. If eye irritation persists: Get medical advice or
attention.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Diethylene glycol monoethyl ether 111-90-0 3 - 7%
Tributoxyethyl phosphate 78-51-3 1 - 5%
Zinc ammonium carbonate 40861-29-8 > 0.1 - < 1%
Polyoxyethylene tridecyl ether phosphate 9046-01-9 > 0.1 - < 1%
Alcohol, C12-C15, ethoxylated 68131-39-5 > 0.1 - < 1%
Ethoxylated secondary alcohol 84133-50-6 > 0.1 - < 1%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes. If eye irritation persists: Get medical advice/attention.
Skin: No specific first aid measures are required.
Inhalation: No specific first aid measures are required.
Ingestion: Rinse mouth with water.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Wash thoroughly after handling. Avoid prolonged or repeated contact with skin. Avoid contact with eyes. FOR COMMERCIAL AND
INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: This product, as supplied, does not contain any hazardous materials with occupational exposure limits
established by the region specific regulatory bodies.
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Unlikely to be irritant in normal use.
Eye contact: Causes eye irritation. Symptoms may include discomfort, redness, and watering.
Ingestion: May be irritating to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May be irritating to nose, throat, and respiratory tract. Symptoms may include coughing and difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Diethylene glycol monoethyl ether 111-90-0 3 - 7% X
Zinc ammonium carbonate 40861-29-8 > 0.1 - < 1% X
Canadian Regulations
Health 1
Flammability 0
Instability 0
Special Hazards -
Revision: 2019-05-30
Version: 05.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
BonaSuper
Cour
t®OPTUM™
Revision: 2019-06-13 Version: 01.0
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
Precautionary Statements
None required.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Dipropylene glycol methyl ether 34590-94-8 3 - 7%
Propylene glycol 57-55-6 0.5 - 1.5%
Tributoxyethyl phosphate 78-51-3 0.5 - 1.5%
Undiluted Product:
Eyes: Rinse with plenty of water. If irritation occurs and persists, get medical attention.
BonaSuper
Cour
t®OPTUM™ 1 of 4
Skin: No specific first aid measures are required.
Inhalation: No specific first aid measures are required.
Ingestion: Rinse mouth with water.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin and eyes. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
BonaSuper
Cour
t®OPTUM™ 2 of 4
Sustained combustion: Not applicable
Explosion limits: - upper: Not determined - lower: Not determined
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Unlikely to be irritant in normal use.
Eye contact: May be mildly irritating to eyes.
Ingestion: No information available.
Inhalation: No information available.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
BonaSuper
Cour
t®OPTUM™ 3 of 4
International Inventories at CAS# Level
All components of this product are listed on the following inventories: U.S.A. (TSCA), Canada (DSL).
CERCLA/ SARA
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Dipropylene glycol methyl ether 34590-94-8 3 - 7% X
Canadian Regulations
Health 1
Flammability 1
Instability 0
Special Hazards -
Revision: 2019-06-13
Version: 01.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
BonaSuper
Cour
t®OPTUM™ 4 of 4
SAFETY DATA SHEET
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
CAUSES SERIOUS EYE IRRITATION.
Precautionary Statements
Avoid contact with eyes, skin and clothing. Wash affected areas thoroughly after handling. May cause irritation to mouth, throat and stomach. Wear
chemical-splash goggles and chemical-resistant gloves. IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water. IF IN EYES: Rinse
cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least 15 minutes. If eye irritation
persists: Get medical advice or attention. Dispose of in accordance with all federal, state and local applicable regulations.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Extraction SC Carpet Extraction Cleaner 1 of 5
Classified Ingredients
Ingredient(s) CAS # Weight %
Alcohol, C9-C11, ethoxylated 68439-46-3 5 - 10%
Sodium xylene sulfonate 1300-72-7 1 - 5%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes. If eye irritation persists: Get medical advice/attention.
Skin: No specific first aid measures are required.
Inhalation: No specific first aid measures are required.
Ingestion: IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water.
Diluted Product:
Eyes: Rinse with plenty of water.
Skin: No specific first aid measures are required
Inhalation: No specific first aid measures are required
Ingestion: IF SWALLOWED: Call a Poison Center (1-800-851-7145) or doctor/physician if you feel unwell.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Do not taste or swallow. Product residue may remain on/in
empty containers. All precautions for handling the product must be used in handling the empty container and residue. Remove and wash
contaminated clothing and footwear before re-use.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: This product, as supplied, does not contain any hazardous materials with occupational exposure limits
established by the region specific regulatory bodies.
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Diluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Unlikely to be irritant in normal use.
Eye contact: Causes serious eye irritation. Symptoms may include pain, redness, and watering.
Ingestion: May be irritating to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May be irritating to nose, throat, and respiratory tract. Symptoms may include coughing and difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
Waste from residues / unused products (diluted product): This product, when diluted as stated on this SDS, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
CERCLA/ SARA
Canadian Regulations
Health 2
Flammability 0
Instability 0
Special Hazards -
Diluted Product:
Health 0
Flammability 0
Instability 0
Special Hazards -
Revision: 2019-08-07
Version: 05.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
GP Forward SC
General Purpose Cleaner
Revision: 2019-05-23 Version: 04.0
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
CAUSES SKIN AND SERIOUS EYE IRRITATION.
Precautionary Statements
Avoid contact with eyes, skin and clothing. Wash affected areas thoroughly after handling. May cause irritation to mouth, throat and stomach. Wear
chemical-splash goggles and chemical-resistant gloves. IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water. IF ON SKIN: Wash with
plenty of soap and water. If skin irritation occurs: Get medical advice or attention. IF IN EYES: Rinse cautiously with water for several minutes.
Remove contact lenses, if present and easy to do. Continue rinsing for at least 15 minutes. If eye irritation persists: Get medical advice or attention.
Take off contaminated clothing and wash it before reuse. Dispose of in accordance with all federal, state and local applicable regulations.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Alcohol ethoxylates 68439-46-3 5 - 10%
Sodium xylene sulfonate 1300-72-7 1 - 5%
Monoethanolamine 141-43-5 1 - 5%
β-
Alani
ne,N-
(2-carboxyet hyl
)-N-dodecyl
-,sodi
um 14960-06-6 > 0.1 - < 1%
salt
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes. If eye irritation persists: Get medical advice/attention.
Skin: IF ON SKIN: Wash with plenty of soap and water. If skin irritation occurs: Get medical advice/attention.
Inhalation: No specific first aid measures are required.
Ingestion: IF SWALLOWED: Rinse mouth. Drink a cupful of milk or water.
Diluted Product:
Eyes: Rinse with plenty of water.
Skin: No specific first aid measures are required
Inhalation: No specific first aid measures are required
Ingestion: IF SWALLOWED: Call a Poison Center (1-800-851-7145) or doctor/physician if you feel unwell.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Do not taste or swallow. Product residue may remain on/in
empty containers. All precautions for handling the product must be used in handling the empty container and residue. Remove and wash
contaminated clothing and footwear before re-use. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
GP Forward SC 2 of 5
General Purpose Cleaner
Exposure Guidelines: .
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
Diluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
GP Forward SC 3 of 5
General Purpose Cleaner
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Causes skin irritation. Symptoms may include pain (which may be delayed), redness, and/or discomfort.
Eye contact: Causes serious eye irritation. Symptoms may include pain, redness, and watering.
Ingestion: May be irritating to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May be irritating to nose, throat, and respiratory tract. Symptoms may include coughing and difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
Waste from residues / unused products (diluted product): This product, when diluted as stated on this SDS, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
GP Forward SC 4 of 5
General Purpose Cleaner
Alcohol ethoxylates 68439-46-3 - - - -
Sodium xylene sulfonate 1300-72-7 - - - -
Monoethanolamine 141-43-5 X X X -
Methyl glycine diacetic acid 3Na-salt 164462-16-2 - - - -
β-
Alanine, 14960-06-6 - - - -
N-(2-carboxyethyl)-N-dodecyl-,
sodium salt
CERCLA/ SARA
Canadian Regulations
Health 2
Flammability 0
Instability 0
Special Hazards -
Diluted Product:
Health 0
Flammability 0
Instability 0
Special Hazards -
Revision: 2019-05-23
Version: 04.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
GP Forward SC 5 of 5
General Purpose Cleaner
SAFETY DATA SHEET
1. IDENTIFICATION
2. HAZARDS IDENTIFICATION
Hazard Statements
CAUSES SERIOUS EYE DAMAGE.
Precautionary Statements
Causes burns/ serious damage to mouth, throat and stomach. Keep container tightly closed. Avoid contact with eyes, skin and clothing. Wash
affected areas thoroughly after handling. IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel.
Drink a cupful of milk or water. IF INHALED: Remove person to fresh air and keep comfortable for breathing. IF IN EYES: Rinse cautiously with
water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least 15 minutes. Immediately call a Poison
Center (1-800-851-7145) or physician. Dispose of in accordance with all federal, state and local applicable regulations.
Classified Ingredients
Ingredient(s) CAS # Weight %
Cocamidopropyl betaine 61789-40-0 1 - 5%
Lauryl dimethyl amine oxide 1643-20-5 1 - 5%
Alkyl poly glycoside 110615-47-9 1 - 5%
Sodium chloride 7647-14-5 0.5 - 1.5%
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes.
Skin: No specific first aid measures are required.
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or
water.
Diluted Product:
Eyes: Rinse with plenty of water.
Skin: No specific first aid measures are required
Inhalation: No specific first aid measures are required
Ingestion: IF SWALLOWED: Call a Poison Center (1-800-851-7145) or doctor/physician if you feel unwell.
5. FIRE-FIGHTING MEASURES
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Personal precautions: Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
and clean-up methods: a chemical waste container. Use a water rinse for final clean-up.
Handling: Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Do not taste or swallow. Product residue may remain on/in
empty containers. All precautions for handling the product must be used in handling the empty container and residue. Avoid breathing vapors or
mists. Use only with adequate ventilation. Remove and wash contaminated clothing and footwear before re-use.
Storage: Keep tightly closed in a dry, cool and well-ventilated place.
Aerosol Level (if applicable) : Not applicable.
Exposure Guidelines: This product, as supplied, does not contain any hazardous materials with occupational exposure limits
established by the region specific regulatory bodies.
Undiluted Product:
Diluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels.
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: May be mildly irritating to skin. Symptoms may include redness and/or transient discomfort.
Eye contact: Corrosive. Causes serious eye damage. Symptoms may include pain, burning sensation, redness, watering, blurred
vision or loss of vision.
Ingestion: Causes burns/ serious damage to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May cause irritation and corrosive effects to nose, throat and respiratory tract. Symptoms may include coughing and
difficulty breathing.
Waste from residues / unused products (undiluted product): This product, as sold, if discarded or disposed, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
Waste from residues / unused products (diluted product): This product, when diluted as stated on this SDS, is not a hazardous waste
according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of
disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local
laws and regulations.
DOT/TDG/IMDG: The information provided below is the full transportation classification for this product. This description does not account for the
package size(s) of this product, that may fall under a quantity exception, according to the applicable transportation regulations. When shipping
dangerous goods, please consult with your internal, certified hazardous materials specialist to determine if any exceptions can be applied to your
shipment.
CERCLA/ SARA
Canadian Regulations
Health 3
Flammability 0
Instability 0
Special Hazards -
Diluted Product:
Health 0
Flammability 0
Instability 0
Revision: 2019-06-04
Version: 03.0
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.