Professional Documents
Culture Documents
Thank you for purchasing Filtered Bus Board. Filtered Bus Board is low profile power
distribution board with extra filtered output headers. This is ideal bus board for all Konstant
Lab power supplies, but it works with other eurorack power supplies as well.
Bus board contains 18 output headers. 12 direct headers and 6 filtered headers with
LC low pass filters. Filtered headers are dedicated for feeding analog modules which are
sensitive to power quality. Filters reject noise caused by PSU and digital modules by 70%.
Two 4 ways DIP switches can tune filtration capacity when some PSU has starting
problems with big capacity on output. Each power rail is protected against overvoltage for
modules safety. 90% bus board area has high only 11mm with inserted connectors. This
feature makes Filtered bus board ideal solution of power distribution for skiff cases.
Mounting to case:
Modules connection:
!!! Always if you connect new module or rearrange power connection in your synth
please SWITCH POWER OFF to avoid modules or PSU faults!!!
http://konstantlab.audio
Konstant Lab s.r.o. , Lucna 1802/64, 90081 Senkvice, SLOVAKIA
info@konstantlab.audio
DIP Switches
Filtered bus boards come with 2 levers ON and 2 levers OFF on the both DIP
switches. It is the most universal and default setup.
A DIP switch connects capacitors near switches to the filter circuits. One lever for one
capacitor (in total 8 switches for 8 capacitor, 4 for +12 V and 4 for -12 V). In case there is a
lot of noise produced by some module in the system, rest of the levers can be used to
connect more capacitors to decrease noise.
Also sometimes can be necessary to disconnect some capacitor because there can
occur high inrush current during starting sequence of PSU. Some PSU can have issues
with starting because of high capacitor charging current. Switching DIP OFF can helps
improve PSU behavior during the start.
Specs
Positions of holes