The document discusses terms related to flywheels. It defines a flywheel as a heavy rotating body that serves as a reservoir for absorbing and redistributing kinetic energy. It recommends a coefficient of fluctuation between 0.005-0.1 for flywheels used in punching and shearing machines. For cast iron flywheels, it advises designing them with a safety factor of 10-13.
The document discusses terms related to flywheels. It defines a flywheel as a heavy rotating body that serves as a reservoir for absorbing and redistributing kinetic energy. It recommends a coefficient of fluctuation between 0.005-0.1 for flywheels used in punching and shearing machines. For cast iron flywheels, it advises designing them with a safety factor of 10-13.
The document discusses terms related to flywheels. It defines a flywheel as a heavy rotating body that serves as a reservoir for absorbing and redistributing kinetic energy. It recommends a coefficient of fluctuation between 0.005-0.1 for flywheels used in punching and shearing machines. For cast iron flywheels, it advises designing them with a safety factor of 10-13.
1. A heavy rotating body which serves as reservior for
absorbing and redisturbing kenetic. a. shaft c. flywheel* b. governor d. puncher
2. Which of the What is the recommended coefficient of
fluctuation of flywheels for punching shearing pressing machine is: a. 0.005-0.1* b. 0.002-0.07 c. 0.03-0.05 d. 0.01-0.
3. A rule of thumb the speed limit of flywheel rim speed
should be 6000 fpm for cast iron material and for cast steel flywheel rim at _______ meters /min A. 3050 C. 7000 B. 4500 D. 10000
4. The cast iron flywheels are commonly designed with a
factor of safety of______ A. 14 to 15 C. 8 to 9 B. 10 to 13 * D. 6 to 12
5. For the rotating elements like flywheels and blowers, the
analysis of stresses will be based similar on which of the following theory? a. thin-walled cylinder b. thick- walled cylinder c. radial ball bearing d. rotating shaft member
6. . In designing the spoke or wheel arm of a flywheel it is
ideal to consider that the cross-sectional area of the spoke at rim side should not be less than ________of the cross area at the hub side A. 80% C. 90% B. 2/3 * D. 3/8
7. The cross-section of the flywheel arms is usually
Select one: a. rectangular b. L-section c. I-section d. elliptical**
8. For punching and shearing machinery a speed variation
of ____ may be allowed in all flywheel design a. 1 to 2% b. 5 to 10% c. 20% d. 50%
9. It equalizes the energy exerted and the work done thus
preventing excessive or sudden changes of speed. a. Flywheel b. Balance wheel c. All of these d. Flywheel pulley