Professional Documents
Culture Documents
Bearing Selection
Operating conditions
Speed [rpm] 15 Length of operation 24
[hours/day]
Operating Temperature High: 78-93°C
Contamination High
Load High
Shock Load Yes
Ambient Temperature Above 40 °C
Shaft Orientation Horizontal
Replenishment Through W33 groove
Rotating Outer Ring No
Grease LGHB 2
Operational Results
Corrected Interval 720 h
Dialset setting compensated for higher ambient temperatures. The setting time is not the same as dispense time. See instruction for
use.
In case of ingress of contamination, more frequent relubrication than indicated by the relubrication interval will reduce the negative
effects of foreign particles on the grease while reducing the damaging effects caused by overrolling the particles. Fluid contaminants
(water, process fluids) also call for a reduced interval. In case of severe contamination, continuous relubrication should be considered.
Specified speed is below 25 RPM which is too low. A speed value of 25 RPM has been used in the calculations
At low speeds, consider a much higher feed rate to keep contamination out. Please contact SKF for more information.
https://dialset.skf.com/dialsetting 1/1