Professional Documents
Culture Documents
Heater 2
Using Keypad
Heater 1
Heater panel
Heater 2 Reset
Heater 1 Set
Control panel
Home Screen icons
Display the Settings panel Start the heating process on heater 1 and 2
Power source type View splice data after splicing
Change image view Adjust the zoom of a fiber image
Display/Non-display icons Adjust display brightness
Start the splicing process Adjust the focus of a fiber image
■Settings panel
To display the Settings panel, tap the
Settings panel icons
Settings panel icon ( ) on Home screen.
Log in to Administrator
mode by entering passcode.
Adjust the volume.
Operating Procedures
1 Splice program setting
1. Tap the Splice program label 2. Select fiber category. 3. Tap the splice program you
on the Settings panel. would like to use.
* Setup and change the Heater program in the same procedures as described above.
1. Tap Arc Test icon ( ). 2. After “Arc Test Ready” 3. When the splicer shows
appears, tap Set icon . An “Good arc state”, prepare fiber
arc test is started. again to proceed to the
splicing process. *Fibers are
not spliced in the arc test.
1. Tap Set icon or press 2. Fusion splicing is completed. 3. Open the wind hood. A proof
Set key to start the test is automatically carried
splicing process. out.
Pre-heating*
Heating in progress
4. Remove the fiber from the
splicer. Center the protection Cooling
sleeve over the splice and 5. Press Heater key to
load the fiber in the heat start the heating process. *”Quick” heater program only
shrink oven.
Sumitomo Electric Industries, Ltd. reserves the right to change the specification or design without OME1624024/Ver.1.04
notice and may therefore not coincide with the contents of this quick reference guide. E&OE
For further detailed operating instructions and functions, please see Operation manual.
The Operation manual can be downloaded via http://www.rim-plus.sei.co.jp/index.html *AS24F702*