Professional Documents
Culture Documents
Design data:
Live load= 4 kPa
Floor finish= 1 kPa
Ceiling load= 0.25 kPa
fc'= 21 MPa
fy= 276 MPa
Use 12 mm diameter as main reinforcement.
Use 10 mm diameter as secondary reinforcement.
1. Compute the minimum thickness of the slab.
A. 110 mm C. 90 mm
B. 120 mm D. 100 mm
2. Using the minimum thickness of the slab, compute the maximum negative factored moment.
A. 5.87 kN-m C. 10.06 kN-m
B. 7.83 kN-m D. 8.19 kN-m
S2
F
C I
8. Calculate the required area (mm2) of tension bars at B and E for beam BE.
A. 900.5 C. 835.7
B. 1023.4 D. 1120.5
9. Calculate the total ultimate uniformly distributed load (kN/m) per 1-m width of slabs.
A. 31.80 C. 30.87
B. 33.96 D. 29.79
10. Calculate the required spacing (mm) of the bottom main bars of the span bounded by ADEB. Use ACI moment coefficient in the analysis.
A. 200 C. 250
B. 225 D. 275
SITUATION 4: When the columns at F and G of the floor framing plan shown are deleted, girder EFGH becomes one span fixed ended beam supporting beam BFJ at F and CGK at G. While beam BFJ and CGK
becomes two-span fixed ended beams. Service floor loads are as follows:
Use A36 steel (Fy = 248 MPa and Fu = 400 MPa) and LRFD. Concrete unit weight is 23.5 kN/m3 and self-weight of beams BFJ and CGK is 30 kg/m. Required strength = 1.2D + 1.6L.
Dimensions: S1 = 2.5 m; S2 = 2 m; S3 = 2 m; L1 = 6 m; L2 = 6 m
11. Calculate the transmitted concentrated ultimate load (kN) by beam BFJ to girder EFGH at F.
A. 276.30 C. 333.45
B. 245.84 D. 321.67
12. Calculate the transmitted concentrated ultimate load by beam CGK to girder EFGH at G.
A. 276.30 C. 333.45
B. 245.84 D. 321.67
13. Calculate the ultimate moment (kN-m) at E.
A. 372.50 C. 333.45
B. 405.33 D. 321.67
15. If the concrete slab provides full lateral support at the top of the girder, calculate the utilization ratio of girder EFGH in flexure.
A. 0.72 C. 0.45
B. 0.55 D. 0.85