Professional Documents
Culture Documents
Instruction Manual: Darimo Seatpost T1 Loop -Assembling the seatpost in the frame:
Thank you for buying a Darimo product. We design from the very first steps to the The seatpost has two white marks at the back.
handcrafted laminates to exceed your expectations in our products.
Adjust the height of the seatpost for your needs. If the length is ok, the clamping
It is very important to follow the installation instructions to ensure proper point will be between the two white marks.
operation of the product. Improper installation can cause damages and will reduce
the safety of the components. Never install a seatpost in a frame if neither mark is visible (the seatpost is too
long) or both marks are visible (the seatpost is too short).
You will need a torque wrench to adjust the torque without exceeding the
You must use a screw seat clamp to control
recommendations. If you do not feel qualified to install the seatpost, ask for a bike
professional to do it. If any doubt, please contact us. the correct torque with a torque wrench. Less
torque than the recommended can take down
-Before assembling: the seatpost during its use. We recommend to
tight to the lower torque. If the seatpost goes
Sandpaper is delivered with the seatpost. Review all sharp down, increase the torque without surpassing
edges of the seatpost clamping area in your bike, both, the maximum torque. Overtightening above
the upper edge of the seat tube and the vertical cut. Sand the recommended values will damage the
the vertical and horizontal edges to smooth any sharp seatpost compromising its strength, safety.
edge that could damage the carbon fibers of the seatpost. The damage will not be covered by warranty.
Clean with a wipe the inside of the seat tube to a depth of about 8 cm. That will The maximum torque for the seat
remove any grease which will prevent proper fastening of the seat post. Insertion limits.
clamp is 6 Nm. Torque 4-6 Nm.
Inside the box you will find a small canister with mounting paste. Apply a thin layer
of it on the seatpost section that will be introduced in the frame. Apply paste inside
the seat tube of the frame too. This paste will reduce the necessary torque to keep
the seat in its position during use. Do not use grease. Use specifically mounting
paste for carbon fiber products.