The document reports girth gear axial readings for Kiln 8 at the Saudi Cement Company after full welding on April 26, 2018. Axial readings were taken at 12 positions around the left and right sides of the gear and the average difference between each left-right pair was calculated. The minimum average difference was -0.57 mm, maximum was 0.11 mm, with a maximum minus minimum of 0.68 mm. The calculated axial runout was +/- 0.34 mm, which is within the allowable limit of +/- 0.75 mm.
The document reports girth gear axial readings for Kiln 8 at the Saudi Cement Company after full welding on April 26, 2018. Axial readings were taken at 12 positions around the left and right sides of the gear and the average difference between each left-right pair was calculated. The minimum average difference was -0.57 mm, maximum was 0.11 mm, with a maximum minus minimum of 0.68 mm. The calculated axial runout was +/- 0.34 mm, which is within the allowable limit of +/- 0.75 mm.
The document reports girth gear axial readings for Kiln 8 at the Saudi Cement Company after full welding on April 26, 2018. Axial readings were taken at 12 positions around the left and right sides of the gear and the average difference between each left-right pair was calculated. The minimum average difference was -0.57 mm, maximum was 0.11 mm, with a maximum minus minimum of 0.68 mm. The calculated axial runout was +/- 0.34 mm, which is within the allowable limit of +/- 0.75 mm.