Professional Documents
Culture Documents
B. 1 kV
C. 66 kV
D. 33 kV
Question ID : 9277592065
Status : Answered
Chosen Option : B
Q.2 Which of the following is/are said to be internal risk factor(s) for an entrepreneur?
Ans A. Health and safety risk
B. Employee risk
D. Compliance risk
Question ID : 9277592071
Status : Not Answered
Chosen Option : --
Q.3
Question ID : 9277591990
Status : Answered
Chosen Option : D
Q.4 ___________ is used for execution of a program.
Ans A. Data memory
B. System memory
C. User memory
D. Executive memory
Question ID : 9277592087
Status : Answered
Chosen Option : D
Q.5 For which type of motor are both the given characteristics true?
B. Series motors
Question ID : 9277591993
Status : Answered
Chosen Option : B
Q.6 Which of the following auxiliaries is essential for starting the generating unit of a hydro
plant?
Ans A. Gate hoists
B. Exciter
Question ID : 9277592041
Status : Not Answered
Chosen Option : --
Q.7 Which of the following symbols belongs to the lamp and lightning apparatus, that is group
of three 40 W fluorescent lamps?
Ans
A.
B.
C.
D.
Question ID : 9277592007
Status : Answered
Chosen Option : B
Q.8 Which of the following is NOT an advantage of Pulse Duration Modulation (PDM) recording?
Ans A. It has high S/N ratio.
B. It has a less complex electronic circuitry and therefore the reliability of such system
is high.
C. It has high accuracy due to the fact that it can be self-calibrated.
Question ID : 9277591964
Status : Not Answered
Chosen Option : --
Q.9 Which of the following parameters is mostly caused by leakage over the insulators, and is
always neglected in a power transmission line?
Ans A. Shunt conductance
B. Inductance
C. Capacitance
D. Resistance
Question ID : 9277592054
Status : Answered
Chosen Option : D
Q.10 ________ is a conductor from which tapings are taken for supply to the consumers.
Ans A. Delivery unit
B. Feeder
C. Service main
D. Distributor
Question ID : 9277592067
Status : Answered
Chosen Option : C
Q.11 When light is produced by fittings that throw all the light on the ceiling, from where it is
reflected to the area to be lighted, this method of lightning arrangement is known as:
Ans A. indirect lightning arrangement
C. semi-direct system
Question ID : 9277592022
Status : Not Answered
Chosen Option : --
Q.12 Which of the following must NOT be considered while drawing a schematic diagram?
Ans A. Branched circuits of equal importance should be drawn similar to one another.
C. Switches, push buttons and contacts should be drawn in such a way that their
movement is from left to right.
D. The supply lines should be drawn horizontally while the different circuit connections
should be drawn vertically.
Question ID : 9277592008
Status : Not Answered
Chosen Option : --
Q.13 The no-load current drawn by a transformer is usually ___________ of the full-load current.
Ans A. 2 to 5 percent
B. 15 to 20 percent
C. 10 to 15 percent
Question ID : 9277591988
Status : Answered
Chosen Option : A
Q.14 ___________ converts binary-coded information to unique outputs such as decimal, octal
digits, etc.
Ans A. Encoder
B. Multiplexing
C. Demultiplexing
D. Decoder
Question ID : 9277591979
Status : Not Answered
Chosen Option : --
Q.15 One of the following instruments is used to measure AC current only. Identify that
instrument.
Ans A. Induction type ammeter
B. Megger
C. Multiplexer
Question ID : 9277591965
Status : Answered
Chosen Option : A
Q.16 Which of the following is NOT one of the methods to improve string efficiency of insulators?
Ans A. Grading of insulators
B. Selection of m
C. Disc porosity
D. Guard ring
Question ID : 9277592064
Status : Answered
Chosen Option : B
Q.17 The ratio of energy obtained from a battery while discharging to energy given to the battery
while charging is:
Ans A. AH efficiency
B. D/C efficiency
C. KW efficiency
D. WH efficiency
Question ID : 9277592002
Status : Answered
Chosen Option : A
B. Percent controlled
C. Uncontrolled
D. Half controlled
Question ID : 9277592000
Status : Not Answered
Chosen Option : --
Q.19 Which of the following is one of the categories of core loss in a DC machine?
Ans A. Friction loss
C. Hysteresis loss
D. Windage loss
Question ID : 9277591991
Status : Answered
Chosen Option : C
Q.20 Figure out the INCORRECT reason from the below points for which 'ash' needs to be
quenched before handling in steam power plant?
Ans A. Quenching maintains corrosion action of the ash.
D. Ash forms clinkers by fusing in large lumps and by quenching clinkers will
disintegrate.
Question ID : 9277592032
Status : Not Answered
Chosen Option : --
Q.21 Which of the following is NOT one of the factors that affects the speed of DC motors?
Ans A. The voltage across the armature
B. The flux
Question ID : 9277591994
Status : Answered
Chosen Option : D
Q.22 Which of the following is NOT a correct component of a modern steam power plant?
Ans A. Induced draught mill.
B. Switch yard
C. Ash precipitators
D. Wagon tippler
Question ID : 9277592028
Status : Not Answered
Chosen Option : --
Q.23 Low line (LT) maintenance does NOT include:
Ans A. removal of bird nests
B. alignment of poles
C. tree clearance
Question ID : 9277592095
Status : Answered
Chosen Option : D
Q.24 Which of the following is NOT an advantage of air blast circuit breakers?
Ans A. This type of circuit breaker is almost maintenance free.
Question ID : 9277592079
Status : Answered
Chosen Option : D
Q.25 Medium transmission lines CANNOT be analysed by using which of the following methods?
Ans A. Load end capacitance
B. Nominal T method
C. Nominal π method
D. Cognitive method
Question ID : 9277592052
Status : Answered
Chosen Option : D
Q.26 The standard voltages for three phase at which the supply authorities deliver power to the
consumer is:
Ans A. 240 V, 50 Hz, 2 wire
Question ID : 9277592010
Status : Answered
Chosen Option : D
Question ID : 9277592047
Status : Answered
Chosen Option : D
Q.28 In _____________, the information from different measuring points is transmitted serially one
after another on the same communication channel.
Ans A. frequency division multiplexing
D. corresponding multiplexing
Question ID : 9277591968
Status : Answered
Chosen Option : A
Q.29 Which of the following is NOT essential in a nuclear-fueled power producing system?
Ans A. A coolant system to remove the heat produced
B. Equipment to convert thermal energy contained in the hot coolant to electric power
Question ID : 9277592044
Status : Not Answered
Chosen Option : --
Q.30
B. Stiffness
C. surface tension
D. Momentum
Question ID : 9277591959
Status : Answered
Chosen Option : C
Q.31 Overheating of an insulator is due to ________ between one metal part to the other. This
causes unequal expansion of porcelain, thus shattering the insulator with cracking.
Ans A. mechanical stress
B. flash-over
C. short-circuit
D. porosity
Question ID : 9277592063
Status : Answered
Chosen Option : A
Q.32 Which of the following points need NOT be considered while selecting type of wiring?
Ans A. Expected future alterations
B. Fire hazards
C. Atmospheric hazards
Question ID : 9277592014
Status : Not Answered
Chosen Option : --
C. speed-torque characteristics
D. torque-flux characteristics
Question ID : 9277591996
Status : Answered
Chosen Option : C
C. distribution switchgear
D. compartmented switchgear
Question ID : 9277592074
Status : Answered
Chosen Option : C
Q.35 From the following options, the most suitable place to install the main switch board is:
Ans A. at/near the entrance of the building
Question ID : 9277592015
Status : Answered
Chosen Option : A
Q.36 Which of the following is NOT the reason behind selecting marble for making 'formers' for
inductance coils?
Ans A. It can be easily machined.
C. It is comparatively cheap.
D. It is a non-magnetic material.
Question ID : 9277591960
Status : Not Answered
Chosen Option : --
Q.37 Which of the following is an advantage of rheostatic control method (one of the speed
control methods) of DC shunt motor?
Ans A. The method needs economical heat dissipation arrangements.
B. Due to low power losses the method is inexpensive and highly efficient.
D. As armature current is less than field current, rheostat required is of small size and
capacity.
Question ID : 9277591995
Status : Answered
Chosen Option : D
Q.38 Which of the following is NOT necessary to be checked while maintaining stay wire?
Ans A. Corrosion of guy rod and stay wire
Question ID : 9277592096
Status : Answered
Chosen Option : C
Q.39 Which of the following statements is INCORRECT for the electrical conducting material,
copper?
Ans A. Its colour is reddish.
Question ID : 9277591973
Status : Answered
Chosen Option : B
C. Distance protection
Question ID : 9277592075
Status : Answered
Chosen Option : D
Q.41 In 11 kV lines, when conductors are in horizontal or delta formation, _______ is provided.
Ans A. cradle guard
B. square guard
C. box guard
D. cage guard
Question ID : 9277592020
Status : Not Answered
Chosen Option : --
Q.42 Identify the INCORRECT statement with regard to the problems in operating large wind
power generators.
Ans A. Locating a site that has a reasonable average high wind velocity is a must.
B. Large areas of land will be available due to sufficient spacing in wind mill gardens,
which somehow cannot be utilised for other commercial activities.
C. A constant angular velocity is a must for generating AC power and this means very
sensitive governing.
D. At zero velocity conditions, the power generated will be zero and this means some
storage system will have to be incorporated along with the windmill.
Question ID : 9277592049
Status : Not Answered
Chosen Option : --
Q.43 In which of the following starters is No Volts Coil (NVC) connected in series with the field
coil?
Ans A. Two point starters
Question ID : 9277591997
Status : Answered
Chosen Option : B
Q.44 The fuses that have a high rupturing capacity and that are available in ratings from 2 to
1250 amperes is:
Ans A. Filler type cartridge fuses
Question ID : 9277592011
Status : Answered
Chosen Option : A
Q.45 ठोस के बल क तुलना म न न म से कौन-सा तेल यु के बल का लाभ नह है?
Ans A. अ धकतम वीकाय तबल बढ़ता है।
B. र के गठन क संभावना समा त हो जाती है।
C. ापना और रखरखाव सरल होता है।
D. इसम और भी अ तरह से संसेचन हो सकता है।
Question ID : 9277592066
Status : Answered
Chosen Option : A
Q.46 The power or strength of the source of light is known as luminous intensity (I) and it is
measured in _______.
Ans A. ampere
B. candela
C. lumen
D. lux
Question ID : 9277592023
Status : Answered
Chosen Option : B
Question ID : 9277592035
Status : Answered
Chosen Option : B
Q.48 The cross-sectional area of a conductor for power wiring should NOT be less than ______ for
a copper wire and ______ for aluminium.
Ans
A.
B.
C.
D.
Question ID : 9277592013
Status : Answered
Chosen Option : B
Q.49 Which of the following is a ferrous metal?
Ans A. Brass
B. Lead
C. Steel
D. Duralumin
Question ID : 9277591969
Status : Answered
Chosen Option : A
Q.50 Which of the following is NOT one of the advantages of an HVDC transmission system?
Ans A. Economical transmission of the bulk power
B. Flexibility in operation
Question ID : 9277592059
Status : Answered
Chosen Option : C
Q.51 __________ is defined as the luminous intensity per unit projected area of the surface in the
given direction.
Ans A. Illumination
B. Lumen
C. Candle power
D. Luminance
Question ID : 9277592103
Status : Answered
Chosen Option : A
B. the combustor
D. turbine
Question ID : 9277592038
Status : Not Answered
Chosen Option : --
Q.53 Which of the following logic functions is used for load connecting "YES" contact to the left-
hand bus bar?
Ans A. NOT
B. LD
C. AND NOT
D. LD NOT
Question ID : 9277592005
Status : Not Answered
Chosen Option : --
Q.54 The simplest form of PLC programming, also known as relay logic, is/are ___________.
Ans A. instruction diagrams
D. ladder diagrams
Question ID : 9277592083
Status : Answered
Chosen Option : A
Q.55 An Act to provide for efficient use of energy and its conservation and for matters connected
therewith or incidental thereto.
The given statement is true for:
Ans A. The Energy Conservation Act, 2001
Question ID : 9277592069
Status : Not Answered
Chosen Option : --
Q.56 Which of the following is NOT an advantage of PLC over electromechanical relay?
Ans A. They are smaller, faster and more reliable that hardwired systems.
B. All devices such as drum, switches, timers and counters are implemented using
physical controllers.
C. They are designed for an electrically noisy environment, so no extra filtering is
required.
D. The outputs may be a mixture of conventional relays and solid-state relays.
Question ID : 9277592082
Status : Not Answered
Chosen Option : --
Q.57 The PLC functions which generate output signals according to logical operations performed
on input signals are known as:
Ans A. timing functions
B. counting functions
D. arithmetic functions
Question ID : 9277592003
Status : Answered
Chosen Option : C
Q.58 Which of the following Port are multifunctional for 8051 microcontroller?
Ans A. Port 1 (Pins 1-8)
C. Port 3 (10-17)
D. Port 0 (32-39)
Question ID : 9277592088
Status : Not Answered
Chosen Option : --
Q.59 The timer on delay instruction is a three word instruction. Which of the following is NOT the
correct word?
Ans A. Accumulator word 2
B. Preset word 1
C. Status word 0
D. Base word 1
Question ID : 9277592089
Status : Not Answered
Chosen Option : --
Q.60 A mechanical switching device used in higher current carrying capacity, having one position
of rest (either open or closed) operated otherwise than by hand, capable of making, carrying
and breaking overload conditions is called:
Ans A. push button
B. limit switch
C. contactor
D. relay
Question ID : 9277592025
Status : Not Answered
Chosen Option : --
Q.61 Solid lump fuels for steam boilers are handled by _______.
Ans A. stokers
B. unit boxes
C. injectors
D. burners
Question ID : 9277592030
Status : Not Answered
Chosen Option : --
Q.62
Question ID : 9277592053
Status : Answered
Chosen Option : D
Q.63 Which of the following is NOT an advantage of pipeline coal transport system for thermal
power plants?
Ans A. It provides simplicity in installation and increased safety in operation.
D. Loss of coal during transport due to theft and pilferage is partially eliminated.
Question ID : 9277592029
Status : Answered
Chosen Option : D
Q.64 Which of the following is NOT an electrical property of material?
Ans A. Conductivity
B. Dielectric strength
C. Inductivity
Question ID : 9277591971
Status : Answered
Chosen Option : D
B. chassis
Question ID : 9277592081
Status : Answered
Chosen Option : B
Question ID : 9277592046
Status : Answered
Chosen Option : B
Q.67 Which of the following is NOT one of the economic advantages of an HVDC transmission
system when compared to an AC transmission system?
Ans A. The HVDC lines can be built in one go, i.e. in a single stage, while the HVAC can be
built in two stages.
B. It requires only one conductor when compared to AC system, which requires several
conductors.
C. The supporting structure required for an HVDC transmission system is narrow,
whereas an AC transmission system requires a lattice structure.
D. Line losses in HVDC transmission are less when compared to AC transmission for
the same power transfer capacity.
Question ID : 9277592057
Status : Answered
Chosen Option : C
Q.68 Which of the following motors is used in refrigeration and air conditioning?
Ans A. Small torque squirrel-cage induction motor for small units
B. DC cumulative motor.
Question ID : 9277592098
Status : Answered
Chosen Option : A
Q.69 From the following options, ________ is the most energy efficient bulb.
Ans A. compact fluorescent light bulb
B. mercury bulb
C. incandescent bulb
D. fluorescent bulb
Question ID : 9277592070
Status : Answered
Chosen Option : A
Q.70 व ुत् इ ी उपकरण के साथ काम करते समय ऊजा बचाने के लए न न ल खत म से कौन सी गलत व ध है?
Ans A. वचा लत लोहे को चालू / बंद करना, कपड़े को इ ी करने के अनुसार इसक गम को नयं त करना।
B. वचा लत तापमान कटऑफ के साथ इ ी ब से का चयन करना।
C. इ ी करते समय अ धक पानी न डालना।
D. गीले कपड़ को इ ी न करना।
Question ID : 9277592068
Status : Answered
Chosen Option : A
B. ECL
C. CMOS
D. TTL
Question ID : 9277591985
Status : Answered
Chosen Option : C
Q.72 Which of the following process is NOT the part of PLC during operation?
Ans A. It executes
B. It opens
C. It writes
D. It reads
Question ID : 9277592084
Status : Answered
Chosen Option : C
Q.73 Choppers do NOT provide:
Ans A. Regeneration
B. Fast response
C. AC regulation
D. Smooth control
Question ID : 9277591999
Status : Answered
Chosen Option : A
Q.74 Which of the following features is NOT desirable while protecting a transmission line?
Ans A. Simultaneous reclosure
Question ID : 9277592076
Status : Answered
Chosen Option : D
Q.75 On which of the following factors does the resistivity of a material NOT depend?
Ans A. Resistance of the conductor
C. Conductor humidity
Question ID : 9277591975
Status : Answered
Chosen Option : C
Q.76 An array of points in three dimensions in which every point has surroundings identical to
that of every other point in the array.
C. Unit cell
D. Space lattice
Question ID : 9277591976
Status : Not Answered
Chosen Option : --
Q.77 A meter reads 117.50 V and the true value of the voltage is 117.42 V. Determine the static
correction for this instrument.
Ans A. -0.08 V
B. -0.92 V
C. 0.08 V
D. 0.92 V
Question ID : 9277591957
Status : Answered
Chosen Option : A
Q.78 Which of the following is NOT one of the most common language structures of PLC
programming?
Ans A. Ladder diagram
B. Function chart
C. Forward language
D. Boolean language
Question ID : 9277592004
Status : Answered
Chosen Option : B
Q.79 1 kg of atomic material (i.e., uranium) can produced as much energy as produced by
burning _________.
Ans A. 300 tonnes of high grade coal.
Question ID : 9277592043
Status : Answered
Chosen Option : A
Q.80 _________ Contact are used in battery ignition systems, vibrators and electric razors.
Ans A. Tin
B. Tungsten
C. Nickel
Question ID : 9277591972
Status : Answered
Chosen Option : C
Q.81 Which of the following is an INCORRECT advantage of gas turbine power plants over diesel
power plants?
Ans A. Gas turbine power plants have lower installation and maintenance cost.
Question ID : 9277592037
Status : Answered
Chosen Option : D
Q.82 Which of the following is NOT one of the materials used for HT (11 kV) and LT (415 V)
distribution lines?
Ans A. Street viewing light fittings
B. Guarding wires
C. Anticlimbing devices
Question ID : 9277592019
Status : Answered
Chosen Option : C
Q.83 The rod and pipe electrodes should NOT be less than _________ in length.
Ans A. 6 m
B. 2.5 m
C. 1.5 m
D. 15 m
Question ID : 9277592012
Status : Answered
Chosen Option : C
Q.84 The horizontal distance between two consecutive supports of an overhead line is called
________.
Ans A. sag
C. span
D. length of span
Question ID : 9277592021
Status : Answered
Chosen Option : C
Q.85 न न म से कौन सी पवन ऊजा क एक कमी है?
Ans A. ाकृ तक प से इनम उतार-चढ़ाव होता है।
B. पवन ऊजा णा लयां वायुमंडल को षत नह करती ह।
C. यह ऊजा का नवीकरणीय ोत है।
D. इसम धन का ावधान और प रवहन क आव यकता नह होती है।
Question ID : 9277592048
Status : Answered
Chosen Option : A
Q.86
B. refrigerator
C. air conditioner
D. water cooler
Question ID : 9277592099
Status : Answered
Chosen Option : B
Q.87 Which of the following statements is NOT true for transpositions of conductors?
Ans A. It refers to exchanging the positions of power conductors at regular intervals along
the line.
B. The flux due to the zero phase sequence or longitudinal current is unaffected by
transpositions of power systems.
C. It results in the increase of electromagnetically induced EMF on the wires.
Question ID : 9277592055
Status : Answered
Chosen Option : C
Q.88
B. existing cable
C. overhead line
D. underground cable
Question ID : 9277592006
Status : Answered
Chosen Option : D
B. silver
C. zinc
D. lead
Question ID : 9277591978
Status : Not Answered
Chosen Option : --
Question ID : 9277592001
Status : Answered
Chosen Option : A
B. Simple and accurate pressure control can be made either by manual or fully
automatic switches.
C. This system is free from dirt.
D. Special type of heating can be done very accurately by electric heating system.
Question ID : 9277592100
Status : Answered
Chosen Option : B
Q.92 Which of the following is NOT one of the advantages of a single three-phase transformer
bank over a three single-phase transformer bank?
Ans A. The core is of larger size which makes it robust.
B. It weighs less.
Question ID : 9277591992
Status : Not Answered
Chosen Option : --
Question ID : 9277591987
Status : Answered
Chosen Option : B
B. Voltmeter
C. Tangent galvanometer
D. Ammeter
Question ID : 9277591955
Status : Answered
Chosen Option : D
B. SIEMENS
C. MODICON
D. ALLEN Bradley
Question ID : 9277592085
Status : Answered
Chosen Option : A
B. negative meter
D. AC ammeter
Question ID : 9277591963
Status : Answered
Chosen Option : D
Q.97 Which of the following is NOT one of the factors that effects the schedule of new business
initiations?
Ans A. Weather conditions
B. Government policies
C. Profitability
D. Consumer expenditure
Question ID : 9277592072
Status : Answered
Chosen Option : A
B. Radiation pyrometers
C. Thermocouples
D. Semiconductor thermometers
Question ID : 9277591966
Status : Answered
Chosen Option : A
Q.99 When AC flows in the conductor the current is non-uniformly distributed over the whole
cross-section of the conductor, due to which outer filaments of the conductor carry more
current then the filaments closer to the centre. This results in a higher resistance to AC than
to DC and is known as the __________.
Ans A. surrogacy effect
B. proximity effect
C. spirality effect
D. skin effect
Question ID : 9277592056
Status : Answered
Chosen Option : D
Q.100 A 4.0 ampere ammeter has a resistance of 0.01 Ω. Determine the efficiency of the
instrument.
Ans A. 25.01 A/W
B. 25 A/W
C. 1.6 A/W
D. 16 A/W
Question ID : 9277591962
Status : Answered
Chosen Option : C
Q.101 ________ is also called an anti-coincidence gate or inequality detector.
Ans A. NOR gate
B. OR gate
C. X-NOR gate
D. X-OR gate
Question ID : 9277591981
Status : Not Answered
Chosen Option : --
B. periodic
C. Process
D. programmable
Question ID : 9277592080
Status : Answered
Chosen Option : D
Question ID : 9277592016
Status : Not Answered
Chosen Option : --
Question ID : 9277592050
Status : Answered
Chosen Option : D
Q.105 EQU, LES, LEQ instructions are examples of which of the following instructions?
Ans A. Composite instructions
B. Comparison instructions
C. Sequencer instructions
Question ID : 9277592091
Status : Not Answered
Chosen Option : --
Q.106 Which of the following methods of starting is required for slip ring induction motors of high
rating?
Ans A. Direct on line starters
B. Auto-transformer starters
Question ID : 9277592017
Status : Answered
Chosen Option : B
Q.107 Which of the following is the dis-advantage of the underground power station?
Ans A. Better rock bearing properties
Question ID : 9277592042
Status : Not Answered
Chosen Option : --
Q.108 Which of the following is an INCORRECT advantage of gas turbine power plants over steam
power plants?
Ans A. Storage of fuel is much smaller and handling is easy.
B. The gas turbine plant as peak load plant is more preferable as it can be brought on
load quickly and surely.
C. The gas turbine plants can work quite economically for short running hours.
D. The thermal efficiency of the gas turbine plant increases below 550°C.
Question ID : 9277592039
Status : Not Answered
Chosen Option : --
Q.109 What is the function of wrenches, used for distribution line maintenance?
Ans A. Used to tighten screws of fixed sizes
B. Used to provide grip to apply torque for turning objects such as nuts or bolts.
D. Used to allow rotary motion in only one direction and prevent the motion in the
opposite direction.
Question ID : 9277592094
Status : Not Answered
Chosen Option : --
Q.110 A ________ arithmetic circuit adds two binary digits, giving a sum bit and a carry bit.
Ans A. half-adder
B. full-adder
C. full-subtractor
D. half-subtractor
Question ID : 9277591982
Status : Answered
Chosen Option : B
B. alumina
C. electrolytic copper
D. porcelain
Question ID : 9277592078
Status : Answered
Chosen Option : A
Q.112 Which of the following is NOT one of the types of equipment communicating with each
other in a SCADA system?
Ans A. RTU (Remote terminal unit)
Question ID : 9277592092
Status : Answered
Chosen Option : A
Q.113 The feature desired for bus protection does NOT include:
Ans A. Separate control of trip circuit of each circuit-breaker
Question ID : 9277592077
Status : Not Answered
Chosen Option : --
Q.114 ________ is NOT one of the application fields of a diesel power plant.
Ans A. Central stations with capacity of 10-50 MW
B. Standby units
C. Mobile plants
Question ID : 9277592034
Status : Answered
Chosen Option : A
B. A parallel-in serial-out shift register is used to convert parallel data to serial data.
C. Shift registers are used for data transfer and data manipulation.
D. The serial-in serial-out and parallel-in parallel-out shift registers are used to maintain
time promptness to digital circuits.
Question ID : 9277591983
Status : Not Answered
Chosen Option : --
B. Piezoelectric
C. Thermocouple
Question ID : 9277591956
Status : Answered
Chosen Option : D
Question ID : 9277591977
Status : Answered
Chosen Option : A
Q.118 _______ is NOT one of the main components of a nuclear power plant.
Ans A. Steam generator
B. Extender
C. Nuclear reactor
D. Electric generator
Question ID : 9277592045
Status : Answered
Chosen Option : A
Q.119 Select the factor that should NOT be considered while selecting the site for a hydro-electric
plant.
Ans A. Accessibility of the site
B. Sedimentation
D. Availability of water
Question ID : 9277592040
Status : Answered
Chosen Option : B
B. low velocity
C. static
D. displacement
Question ID : 9277591961
Status : Answered
Chosen Option : A
Q.121 Which of the following is NOT one of the commonly used equipment for ash handling in
large and medium size steam power plants?
Ans A. Trollies or rail cars.
B. Pneumatic conveyor.
C. Bucket conveyor
D. Belt elevator
Question ID : 9277592033
Status : Not Answered
Chosen Option : --
Q.122 Insulating materials such as cotton or oiled cambric are used for which part of
transformers?
Ans A. Air cooled and oil cooled transformers
Question ID : 9277591974
Status : Answered
Chosen Option : D
Q.123 For ___________, the frequency range is limited to a maximum of about 5 KHz.
Ans A. piezoelectric microphones
B. carbon microphones
C. capacitive microphones
D. dynamic microphones
Question ID : 9277591967
Status : Not Answered
Chosen Option : --
Question ID : 9277592086
Status : Not Answered
Chosen Option : --
Q.125 न न म से कौन-सा अनु योग पॉवर लांट इंजी नय रग के उ े य से गैस टरबाइन लांट के लए गलत है?
Ans A. सहायक यं क यां क ाइव क आपू त करना
B. अ ा ह सा लोड द ता पॉवर लांट के प म काय करना
C. पारंप रक भाप बॉयलर के साथ संयोजन संयं ( लांट) के प म काम करना
D. जनरेटर चलाने और भाप, डीजल या हाइ ो लांट म पीक लोड क आपू त करना
Question ID : 9277592036
Status : Not Answered
Chosen Option : --
Q.126 Internal combustion engine drive used for road transport is a type of:
Ans A. Non-electric traction system
Question ID : 9277592097
Status : Answered
Chosen Option : A
Q.127 Which of the following is an INCORRECT reason due to which instrumental errors arise?
Ans A. Partial measuring experience of measurer in the instruments
Question ID : 9277591958
Status : Answered
Chosen Option : A
Q.128
B. induced link
C. monopolar link
D. biopolar link
Question ID : 9277592058
Status : Answered
Chosen Option : B
Q.129 The electrical energy available from __________ is meant for general sale to the customers
who wish to purchase it.
Ans A. reserved power stations
C. central stations
Question ID : 9277592027
Status : Answered
Chosen Option : C
B. square counters
C. VLSI counters
D. SSI counters
Question ID : 9277591984
Status : Not Answered
Chosen Option : --
Q.131 Which of the following is used by the serial port to control data rates?
Ans A. Register SBUF
C. Register SCON
D. Register PCON
Question ID : 9277592090
Status : Answered
Chosen Option : B
Q.132 The electrical connections can be ensured between the commutator as well as exterior load
circuit with the help of:
Ans A. poles shoe
B. Shaft
C. Poles
D. Brushes
Question ID : 9277591989
Status : Answered
Chosen Option : D
Q.133
C. Chassis connection
D. Screened fault
Question ID : 9277592009
Status : Answered
Chosen Option : A
Q.134 Which type of chopper circuit is generally used for the reversible DC motor and
corresponding breaking operation?
Ans A. Type D chopper
B. Type E chopper.
C. Type A chopper
D. Type C chopper
Question ID : 9277591998
Status : Not Answered
Chosen Option : --
Question ID : 9277592073
Status : Answered
Chosen Option : D
Question ID : 9277592102
Status : Not Answered
Chosen Option : --
Q.137 One of the most commonly used materials for insulators of an overhead transmission line,
i.e. glass, has the drawback (when used as an insulator material) that:
Ans A. moisture condenses more readily on its surface
Question ID : 9277592061
Status : Answered
Chosen Option : B
Q.138 When the length of an overhead transmission line is less than 80 km with an operating
voltage upto 20 kV, it is considered to be a/an ___________.
Ans A. long transmission line
D. ultra-long transmission
Question ID : 9277592051
Status : Answered
Chosen Option : B
Q.139 _________ are those materials in which valence electrons are very tightly bound to their
parent atoms thus requiring a very large electric field to remove them from attraction of
nuclei.
Ans A. Conductors
B. Insulators
C. Magnetic materials
D. Semiconductors
Question ID : 9277591970
Status : Answered
Chosen Option : B
Q.140 The information is embedded in the ROM, in the form of bits, by a process known as
________ the ROM.
Ans A. Retrieving
B. Programming
C. Copying
D. Reading
Question ID : 9277591986
Status : Answered
Chosen Option : C
Q.141 Which of the following is used in household applications such as washing machines, ceiling
fans and water coolers?
Ans A. Squirrel cage induction motor
Question ID : 9277592024
Status : Answered
Chosen Option : C
Q.142 Which of the following is NOT an essential requirement of steam power station design?
Ans A. Maximum capital cost
B. Extensibility
D. Reliability
Question ID : 9277592031
Status : Not Answered
Chosen Option : --
Q.143 Which of the following is NOT necessary to check in air break switches maintenance?
Ans A. Missing of the lock
D. Blades/contact burning
Question ID : 9277592101
Status : Not Answered
Chosen Option : --
Q.144 The relative permeability of _________ materials is slightly less than unity.
Ans A. anti-ferrimagnetic
B. diamagnetic
C. paramagnetic
D. Ferromagnetic
Question ID : 9277591980
Status : Answered
Chosen Option : B
Q.145 न न म से कौन-सा गुण रोधी लाइन (insulating line) म उपयोग कए जाने वाले रोधी कवर म मौजूद नह
होना चा हए?
Ans A. यह मौसम, यू.वी. (UV), ओजोन आ द के लए तरोधी सा बत होना चा हए।
B. इसम पया त व ुत- ै कग तरोध होना चा हए।
C. यह ठं ड के मौसम क तय के लए पया त यां क तरोध होना चा हए।
D. यह कठोर और ऐ टै ट न र हत होना चा हए।
Question ID : 9277592062
Status : Answered
Chosen Option : C
B. In a simple brayton cycle, the air is first compressed and then compressed air is
heated at constant volume.
C. A gas turbine requires less installation time and cost, is quick in starting and
stopping, and has fast response to load changes.
D. Gas turbines are steady flow power machines in which a gas is compressed, heated
and expanded to generate power.
Question ID : 9277592026
Status : Not Answered
Chosen Option : --
Q.147 __________ is defined as the ratio of the luminous flux to the power input.
Ans A. Luminous intensity
B. Luminous Efficacy
C. Luminance factor
D. Maintenance factor
Question ID : 9277592104
Status : Answered
Chosen Option : B
B. They can take conductor load in tension which often occurs at angles and at dead
ends.
C. Pin insulators can be used upto 33 kV.
Question ID : 9277592018
Status : Answered
Chosen Option : B
Q.149 न न म से कौन-सी आव यकता या गुण लाइन इंसुलेटर के लए आव यक नह होते ह?
Ans A. इ ह छ यु होना चा हए।
B. परावै ुत साम य ब त अ धक होना चा हए।
C. उ ह आंत रक अशु य से मु होना चा हए।
D. दमक वसजन वो टे ज ( लैशओवर वो टे ज) करने के लए उसम पंचर साम य का उ अनुपात होना चा हए।
Question ID : 9277592060
Status : Answered
Chosen Option : A
Q.150 The strategy which involves repair or replacement only when deterioration of the condition
causes functional failure is known as:
Ans A. proactive maintenance
B. preventive maintenance
C. reactive maintenance
D. condition monitoring
Question ID : 9277592093
Status : Answered
Chosen Option : B
Question ID : 9277592111
Status : Answered
Chosen Option : C
B. 3 जुलाई
C. 24 जनवरी
D. 31 अ टू बर
Question ID : 9277592105
Status : Answered
Chosen Option : C
Q.3 भारत म गुलाम वंश क ापना कसने क थी?
Ans A. गयासु न बलबन
B. क़तुब–उद–द न ऐबक
C. ख–उद-द न फरोज़
D. श सु न इ तुत मश
Question ID : 9277592118
Status : Answered
Chosen Option : B
B. सात
C. आठ
D. पांच
Question ID : 9277592108
Status : Answered
Chosen Option : B
Question ID : 9277592107
Status : Not Answered
Chosen Option : --
Q.6 2 दसंबर 2020 को भारतीय क तान वराट कोहली, 12,000 एक- दवसीय रन बनाने वाले सबसे तेज के टर
बन गए थे। इ ह ने ऐसा करके कसका रकॉड तोड़ा था?
Ans A. एस.आर. त लकर
B. एस.ट . जयसूया
C. आर.ट . प टग
D. के .सी. संगकारा
Question ID : 9277592123
Status : Answered
Chosen Option : A
Q.7 न न म से कस भारतीय रा य से बां लादे श क सीमा नह लगती है?
Ans A. असम
B. मेघालय
C. प म बंगाल
D. नागालड
Question ID : 9277592113
Status : Answered
Chosen Option : D
B. र व राय
C. जी.वी. मावलंकर
D. के .एस. हेगड़े
Question ID : 9277592121
Status : Not Answered
Chosen Option : --
Q.9 भगवान गौतम बु के जीवनकाल म ाचीन भारत म कतने महाजनपद या ' े सा ा य' मौजूद थे?
Ans A. 14
B. 10
C. 12
D. 16
Question ID : 9277592117
Status : Not Answered
Chosen Option : --
C. तबला
D. बांसुरी
Question ID : 9277592106
Status : Answered
Chosen Option : D
Question ID : 9277592115
Status : Answered
Chosen Option : B
Q.12 अ टू बर 2020 म आयो जत SCO (शंघाई सहयोग संगठन) के महा भयोजक क 18 व बैठक म भारत का
त न ध व कसने कया था?
Ans A. अटॉन जनरल, के .के . वेणुगोपाल
B. सॉ ल सटर जनरल, तुषार मेहता
Question ID : 9277592120
Status : Answered
Chosen Option : A
Question ID : 9277592124
Status : Answered
Chosen Option : B
B. पु
C. गंगा
D. सतलुज
Question ID : 9277592114
Status : Not Answered
Chosen Option : --
B. वाई.वी. रे ी
C. वजय के लकर
D. अर वद सु म यम
Question ID : 9277592109
Status : Answered
Chosen Option : B
Q.16 न न म से कौन-सा तरंग दै य (wavelength) का तीक च है?
Ans A. हट् ज़ (Hertz)
B. अ फा (Alpha)
C. बीटा (Beta)
D. लै डा (Lambda)
Question ID : 9277592112
Status : Answered
Chosen Option : B
B. तीन
C. एक
D. चार
Question ID : 9277592122
Status : Answered
Chosen Option : A
D. भारतीय रा ीय कां ेस
Question ID : 9277592116
Status : Not Answered
Chosen Option : --
Question ID : 9277592119
Status : Not Answered
Chosen Option : --
Q.20 ___________क बात कर, तो यह जी.डी.पी (GDP) म बढ़ते मू य और अवन त स हत धीमी आ थक वृ और
अपे ाकृ त उ बेरोजगारी क त है।
Ans A. मंद (Depression)
Question ID : 9277592110
Status : Not Answered
Chosen Option : --
Section : Reasoning
Q.1 पांच व ाथ नीतू, अमन, का या, सुनील और मनीषा कू ल क र कग म शीष पाँच रक पर ह। अमन क रक
ठ क नीतू से ऊपर क है। का या क रक सरी है। अमन क रक मनीषा और नीतू के बीच क है।
कू ल म शीष रक कसक है?
Ans A. नीतू
B. अमन
C. सुनील
D. मनीषा
Question ID : 9277592135
Status : Answered
Chosen Option : C
कथन:
जब येक य को को वड-19 का ट का लग जाएगा, तो महामारी समा त हो जाएगी और हम सावज नक
थान पर बना मा क लगाए जा सकगे।
अवधारणा:
I. जब तक को वड-19 महामारी समा त नह हो जाती है, तब तक हम सावज नक थान पर मा क पहनना
चा हए।
II. जब
कसी य को को वड-19 का ट का लग जाता है, तब वह सावज नक थान पर बना मा क लगाए
जा सकता है।
Ans A. के वल अवधारणा I अंत न हत है
Question ID : 9277592141
Status : Answered
Chosen Option : B
Q.3 य द ‘ह रयाणा’ को ‘पंजाब’ कहा जाता है, ‘पंजाब’ को ‘राज थान’ कहा जाता है, ‘राज थान’ को ‘तेलंगाना’ कहा
जाता है, ‘तेलंगाना’ को ‘गुजरात’ कहा जाता है, ‘गुजरात’ को ‘म य दे श’ कहा जाता है और ‘म य दे श’ को
‘असम’ कहा जाता है, तो टे यू ऑफ यू न ट कस रा य म त है?
Ans A. राज थान
B. म य दे श
C. तेलंगाना
D. गुजरात
Question ID : 9277592131
Status : Answered
Chosen Option : B
Q.4 एक न त कू ट भाषा म, Min Fin Dig का अथ "Mohan is doctor" है, और Sic Ric Min Dic Fin का अथ
"Profession of doctor is noble" है।
तो “Mohan” के लए न न ल खत म से कस कोड का उपयोग कया गया है?
Ans A. Dig
B. Fin
C. Min
D. Dic
Question ID : 9277592129
Status : Answered
Chosen Option : A
पाँच ब ,े A, B, C, D, और E, व भ न रंग (मजे टा, नारंगी, बगनी, पीले तथा नीले) के कपड़े पहने ए ह,
ले कन वे अ नवाय प से इसी म म नह पहने ए ह। उनम से येक, आलू, बगन, लौक , फली और
फू लगोभी म से कोई एक स जी पसंद करता है। C ने मजे टा रंग के कपड़े पहने है। B को बगन और लौक पसंद
नह है। D को फली पसंद ह और वह नीले रंग के कपड़े पहने ए है। बगनी रंग के कपड़े पहने ए लड़क को बगन
पसंद ह। E को आलू पसंद ह ले कन वह पीले या बगनी रंग के कपड़े नह पहने ए है। C को लौक पसंद है।
B. B
C. D
D. C
Question ID : 9277592137
Status : Answered
Chosen Option : C
Q.6 एक न त कू ट भाषा म, 5237 का अथ "India is our country" है, और 22637 का अथ "It is famous for
culture" है।
तो उसी कू ट भाषा म "I love my India" के लए या कोड होगा?
Ans A. 2837
B. 1425
C. 1529
D. 7945
Question ID : 9277592128
Status : Answered
Chosen Option : B
Q.7 सात म , रया, म हमा, जगत, कबीर, सीता, तनु और ग रमा एक गोल मेज के प रत: इसके क क ओर
अ भमुख होकर बैठे ह। तनु, ग रमा के दा ओर तीसरे थान पर बैठ है। सीता और जगत, ग रमा के बगल म
नह बैठे ह। सीता ठ क तनु के बा ओर पड़ोस म बैठ है। कबीर ठ क रया और जगत के बीच म बैठा है। सीता
के ठ क बा ओर पड़ोस म कौन बैठा है?
Ans A. तनु
B. रया
C. कबीर
D. म हमा
Question ID : 9277592132
Status : Answered
Chosen Option : D
कारण (R): वटा मन D एक ऐसा व श ट वटा मन है, जो तब न मत होता है जब आपक वचा म मौजूद
कोले ॉल सूय के काश के संपक म आते ह।
Ans A. A' अस य है 'R' स य है।
B. A' और 'R' स य ह और 'R', 'A' का सही प ट करण नह है।
C. A' और 'R' स य ह और 'R', 'A' का सही प ट करण है।
D. A' स य है ले कन 'R' अस य है।
Question ID : 9277592143
Status : Answered
Chosen Option : C
Q.9 दए गए कथन और न कष को यानपूवक पढ़। यह मानते ए क कथन म द गई जानकारी स य है, भले ही
वह सामा य प से ात त य से भ न तीत होती हो, नधा रत क जए क दए गए न कष म से कौन से
न कष कथन का ता कक प से अनुसरण करते ह।
कथन :
कु छ कार वैन ह।
सभी वैन कू टर ह।
सभी कार बस ह।
न कष :
Question ID : 9277592139
Status : Answered
Chosen Option : C
अ भकथन (A): एक वष म सवा धक वषा होने का गनीज व व रकाड चेरापूंजी के नाम है।
कारण (R): चेरापूंजी या सोहरा भारतीय रा य मेघालय के पूव खासी ह स जले म त एक उप-मंडलीय
क बा है।
Ans A. A' और 'R' स य ह और 'R', 'A' का सही प ट करण नह है।
B. A' स य है ले कन 'R' अस य है।
C. A' और 'R' स य ह और 'R', 'A' का सही प ट करण है।
D. A' अस य है 'R' स य है।
Question ID : 9277592144
Status : Answered
Chosen Option : A
Q.11 इस न म एक कथन के बाद दो कायवा हयां I और II द गई ह। यह मानते ए क कथन म द गई सम त
जानकारी स य है, नधा रत क जए क सुझाई गई कौन सी कायवाई ता कक प से कथन का अनुसरण करती
है/ह।
कथन :
टे न म कोरोना वाइरस का नया े न पाया गया है; यह भारत म पाए जाने वाले कोरोना वाइरस से 70% अ धक
खतरनाक है।
कायवाई :
I. भारत को टे न से आने वाली सम त हवाई उड़ान को अगले एक वष के लए तबं धत कर दे ना चा हए।
II. भारत सरकार को चा हए क वह सम त साधन का उपयोग करते ए जनसामा य को यह बताए क
को वड-19 के व लड़ाई अभी जारी है, सावज नक थान पर मा क पहनने तथा एक- सरे से उ चत री
बनाए रखने म कोई चूक न हो।
Ans A. के वल II अनुसरण करता है
B. के वल I अनुसरण करता है
Question ID : 9277592142
Status : Answered
Chosen Option : A
Q.12 सात अलग-अलग रंग (लाल, पीले, हरे, गुलाबी, बगनी, नीले तथा भूर)े के सम प ड बे एक के ऊपर एक के
आधार पर न नानुसार रखे गए ह –
बगनी ड बा बीच म रखा आ है। लाल ड बा ठ क हरे और नीले ड बे के म य म रखा आ है। पीला ड बा
ठ क बगनी ड बे के ऊपर रखा आ है। गुलाबी ड बा सबसे ऊपर रखा आ है।
कस रंग का ड बा नीचे से छठे थान पर रखा आ है?
Ans A. नीला
B. हरा
C. पीला
D. भूरा
Question ID : 9277592133
Status : Answered
Chosen Option : D
B. 32
C. 28
D. 22
Question ID : 9277592125
Status : Answered
Chosen Option : A
Q.14 य द 'L', 'Q' का भाई है, 'M', 'L' क प नी है, 'N', 'Q' का पता है, और 'P', 'M' का इकलौता पु है। तो 'P' का 'N' से
या संबंध है?
Ans A. पोता / नाती
B. पता
C. भाई
D. पु
Question ID : 9277592138
Status : Answered
Chosen Option : A
Q.15 एक न त कू ट भाषा म, य द "WALL" को ZEQR लखा जाता है और "DOOR" को GSTX लखा जाता है, तो
उसी भाषा म "ROOM" को या लखा जाएगा?
Ans A. WSTT
B. VTST
C. USTS
D. URRP
Question ID : 9277592127
Status : Answered
Chosen Option : C
B. 32व
C. 25व
D. 36व
Question ID : 9277592134
Status : Not Answered
Chosen Option : --
B. 25
C. 27
D. 20
Question ID : 9277592136
Status : Answered
Chosen Option : C
Q.18 दए गए कथन और न कष को यानपूवक पढ़। यह मानते ए क कथन म द गई जानकारी स य है, भले ही
वह सामा य प से ात त य से भ न तीत होती हो, नधा रत क जए क दए गए न कष म से कौन से
न कष कथन का ता कक प से अनुसरण करते ह।
कथन :
सभी 'बक रयां' ' ब लयां' ह
सभी ‘ ब लयां’ ‘पशु’ ह।
न कष :
I. सभी 'बक रयां' 'पशु' ह।
II. कु छ ‘पशु’ ‘ ब लयां’ ह।
Ans A. न तो न कष I और न ही II अनुसरण करता है
B. न कष I और II दोन अनुसरण करते ह
C. के वल न कष II अनुसरण करता है
D. के वल न कष I अनुसरण करता है
Question ID : 9277592140
Status : Answered
Chosen Option : D
Q.19 य द ‘बु ह’ को ‘अ ण ह’ कहा जाता है, ‘अ ण ह’ को ‘वृह त ह’ कहा जाता है, ‘वृह त ह’ को
‘मंगल ह’ कहा जाता है, ‘मंगल ह’ को ‘पृ वी ह’ कहा जाता है, ‘पृ वी ह’ को ‘श न ह’ कहा जाता है, ‘श न
ह’ को ‘शु ह’ कहा जाता है, और ‘शु ह’ को ‘ लूटो ह’ कहा जाता है, तो हम कस ह पर रहते ह?
Ans A. श न ह
B. पृ वी ह
C. शु ह
D. मंगल ह
Question ID : 9277592130
Status : Answered
Chosen Option : A
B. 11-9-15-16
C. 12-9-15-14
D. 13-10-14-15
Question ID : 9277592126
Status : Answered
Chosen Option : C
B. तनका
C. यौहार
D. तीखा
Question ID : 9277592146
Status : Answered
Chosen Option : A
B. अ न
C. अ गन
D. आग
Question ID : 9277592147
Status : Answered
Chosen Option : B
B. कपड़ा - कपड़े
C. त थ - त थएँ
D. आदत - आदत
Question ID : 9277592152
Status : Answered
Chosen Option : A
Question ID : 9277592154
Status : Answered
Chosen Option : C
B. ाम
C. गागर
D. गाय
Question ID : 9277592145
Status : Answered
Chosen Option : B
Q.6 न न ल खत म से कौन सा श द अ त सम है?
Ans A. काज
B. कम
C. काय
D. कारज
Question ID : 9277592148
Status : Answered
Chosen Option : D
Question ID : 9277592151
Status : Not Answered
Chosen Option : --
B. पृ वी - वाह
C. धारण करना - वाह
D. पृ वी - लहर
Question ID : 9277592150
Status : Answered
Chosen Option : B
Question ID : 9277592153
Status : Answered
Chosen Option : C
B. ब लदान - वीर
C. बल - वीर
D. ब लदान - लकड़ी
Question ID : 9277592149
Status : Not Answered
Chosen Option : --