Professional Documents
Culture Documents
Technical knowledge
+ Recording point
+ measurement point
+ test point
+ Examination point
A specific location on a piping system to obtain a repeatable thickness measurement for the
purpose of establishing an accurate corrosion rate. CMLs may contain multiple examination
points.
The thinnest reading or an average of several measurement readings taken within the area of
a test point shall be recorded and used to calculate:
a. Corrosion Rates.
b. Remaining Life.
c. Next Inspection Date
The exact area where a thickness test is to be done is known as a test point (definition 3.46).
Even this is not absolutely precise, as the test point is in fact an area bounded
by a circle of a certain maximum diameter (see Fig. 2.4).
https://shipbuildingknowledge.wordpress.com/2020/06/21/api-570-what-is-test-point/ 1/2
21:58 26/05/2023 API 570 – What is Test point??? – General Technical knowledge
Maximum 3
> 10 inch
inch (75 mm)
Figure 2.4 Test point circle diameters
Question:
A test point is an area defined by a circle having a diameter not greater than _____ inches for a
line diameter not exceeding 10 inches or not greater than ______ inches for larger lines.
a. 3, 4
b. 2, 3
c. 1, 2
d. 3/4, 1
Refer:
API 570
Marine & Offshore -Worked at Triyards -Worked at Hyundai Vinashin View all posts by
Thanh Nguyen Le
https://shipbuildingknowledge.wordpress.com/2020/06/21/api-570-what-is-test-point/ 2/2