Professional Documents
Culture Documents
FTS-01 (A + B)
(1) 5 : 4 (2) 3 : 4
(3) 4 : 3 (4) 1 : 1
2. Two particles with masses 2 m and m are
connected by light rods of negligible mass as (1) 250 N (2) 300 N
shown in figure. The rotation is in horizontal plane (3) 450 N (4) 900 N
(1)
CSS-01 Physics
2. In the shown arrangement, the man with mass 70 4. The addition of (34.683 +58.930 + 68.35112) with
2.
kg is accelerating up with an acceleration of 5 m/s correct significant figure is
The mass of trolley used is 30 kg and string is (1) 161.964 (2) 161.9
inextensible and light weight. What is pull exerted (3) 161.95 (4) 161.96
2
by man on the string? (g = 9.8 m/s ) Q.41 (Code-B) (Friction)
1. When a bicycle is in motion but not Pedalled, the
force of friction is exerted by ground on two wheels
along
(1) Backword direction on rear wheel and forward
direction on front wheel
(2) Backward direction on both wheel
(1) 620 N (2) 740 N (3) Forward direction on both wheel
(3) 1000 N (4) 980 N (4) In forward direction on rear wheel and back
3. In trolley string arrangement, a painter is holding word direction on front wheel
string in hands and keeps in equilibrium the entire 2. A man is walking on a plane rough surface,
arrangement. Mass of painter is 60 kg and mass of direction of friction acting on man is
trolley is 20 kg. What is normal force exerted by (1) Opposite to direction of motion
2
trolley floor on painter? (g = 9.8 m/s ) (2) Same as that of direction of motion
(3) Perpendicular to that of direction of motion
(4) 45° to the direction of motion
3. Frictional force acting between two bodies
(1) Supports the motion between two bodies
(2) Oppose the relative motion between the
bodies
(3) sometimes helps and sometime opposes the
(1) 196 N (2) 392 N
relative motion
(3) 588 N (4) Zero
(4) Increases the relative velocity between the
Q.35 (Code-B) (Significant Figures)
bodies
1. A student measures the diameter of a wire using
Q.33 (Code-B) (Application of Newton’s Second law
screw gauge with the least count 0.001 cm. The
of Motion)
measured value should be recorded as
1. A wire of length L and mass M has uniform mass
(1) 5.3200 cm (2) 5.3 cm
density. Determine the ratio of tensions at position
(3) 5.32 cm (4) 5.320 cm
A to position B as shown in diagram.
2. The mass of a box measured by grocer’s balance
is 2.300 kg. Two gold pieces of masses 20.15 g
and 20.17 g are added to the box. The total mass
of the box and the difference in the masses of gold
piece should be recorded
(1) 2340.32 g, 0.02 g (2) 2.340 kg, 0.02 g
(1) 1 : 1 (2) 2 : 1
(3) 2.3 kg, 0 g (4) 2.334032 kg, 0.02 g
(3) 3 : 1 (4) 1 : 2
3. The edge of a cube is measured by a scale of least
2. Determine tension at position P (mid-point) in
count 1 mm. The measured value is l = 1.2 cm. The
given diagram. Consider string AB of mass 2 kg
volume of the cube should be recorded as
has uniform mass density.
(1) (1.728 ± 0.003) cm3 (2) (1.73 ± 0.004) cm3
(3) (1.7 ± 0.4) cm3 (4) (1.7 ± 0.3) cm3
(2)
CSS-01 Physics
of v A
❑ ❑ ❑
(3)
Based On
FTS-02 (A&B)
(1)
CSS-01 Physics
Q.17 (Code-A) (The Work Energy theorem for a 3. Two forces, F1 and F2 are acting on a body. One
variable force) force is doubled of the other force and the resultant
1. A force F = 4x3 – 3x2 + 5 is acting on a body of is equal to the greater force. Then the angle
mass 2 kg. The change in kinetic energy of the between the two forces is
body when it moves from (0,0,0) to (1,2,3) m, will 1 1
(1) = cos –1 (2) = cos –1
be 2 4
(1) 0 J (2) 5 J 1 1
(3) = cos –1 – (4) = cos –1 –
(3) 10 J (4) 20 J 2 4
2. A block of mass 5 kg, moving in the positive x- 4. The magnitude of vector sum of two vectors is
–1
direction with a constant speed of 10 m s . It is equal to the magnitude of difference of the two
subjected to a retarding force F = 0.2 x N during its vectors, the angle between these vectors is
travel from x = 10 m to x = 20 m. Its final kinetic (1) 0° (2) 45°
energy will be (3) 90° (4) 180°
(1) 250 J (2) 200 J Q.9 (Code-B) (Damped simple harmonic motion)
(3) 220 J (4) 280 J 1. Which of the following graph best represents the
3. A force F = 4 xiˆ + 3yjˆ is acting on a body of mass damped harmonic motion?
a2 iˆ + b2 jˆ + c2 kˆ will be
3 ˆj – 4kˆ will be
1 1
(1) = cos –1 (2) = cos –1 – (4)
3 3
2 2
(3) = cos –1 (4) = cos –1 –
3 3
(2)
CSS-01 Physics
(1)
Q.31 (Code-B) (Angular momentum of bodies)
1. A solid cylinder of mass m and radius R is rolling
with angular velocity rad/s on rough, horizontal
surface. The magnitude of angular momentum
about origin is
(2)
(3)
mR 2 3mR 2
(1) (2)
2 2
2mR 2 mR 2
(3) (4)
3 4
(4)
2. A solid sphere is in pure rolling motion with centre
of mass moving with velocity v0 its angular
momentum about point P shown in diagram is
3. In damped oscillation, the graph between velocity
and position will be like
(1)
2 1
(1) mv 0 R (2) mv 0 R
5 5
7
(3) mv 0 R (4) mv 0 R
5
3. A particle is moving on circle as shown. Its angular
(2)
momentum about O is
(3)
(3)
CSS-01 Physics
Q.34 (Code-B) (Centre of mass) Q.38 (Code-B) (Centre of mass of Remaining part)
1. A semicircular portion of radius R is cut from
1. A triangular sheet of uniform thickness is shown in
uniform rectangular plate as shown. The distance
figure. The co-ordinate of centre of mass are of centre of mass C of remaining plate. From point
O is
2R 3R
(1) (1 m, 3 m) (2) (2 m, 3 m) (1) (2)
3(4 – ) 4
(3) (1 m, 2 m) (4) (1.5 m, 3.0 m)
2R
(3) (4) 2R – 1
2. A quarter ring of uniform linear density is placed in (2 – ) 3
x-y plane as shown. The co-ordinate of centre of 2. A uniform metal disc of radius R is placed on a
large disc of 2 R made of same material with half
mass of the given ring is
thickness. The peripheries of two discs touch each
other. Locate the centre of mass of remaining disc
from origin O.
R R R R
(1) , (2) ,
2 2
R R 2R 2R
(3) , (4) ,
2 2 (1) R/18 to left of origin on x-axis
(2) R/5 to left of origin on x-axis
3. A thin uniform wire is bend to form two equal sides (3) R/5 to right of origin on x-axis
AB and AC of triangle ABC where AB = AC = 5 cm. (4) R/15 to right of origin on x-axis
3. A uniform metal disc of radius R is taken out of a
The third side BC, of length 6 cm is made from
large disc of radius 2 R from its end as shown. The
uniform wire of twice the density of the first. The centre of mass of remaining disc will be
distance of centre of mass from A is
❑ ❑ ❑
(4)
CSS-01 Physics
Based on
FTS-01 (A & B)
❑ ❑ ❑
(4)
CSS-07 Chemistry
OYM Based on
FTS-02 (A & B)
(5)