Professional Documents
Culture Documents
Nama Gambar Jumlah Keterangan Aktual Nama Gambar Jumlah Keterangan Aktual
ada with
To lift up thè tractor
Garage Jack Min 1 ada Engine Stand 1 To disassemble and assemble Engine for overhaul transmission
Capacity : over 3 tons
stand
Tractor Disassembling To support tractor Waste Management 1 Oil Drum, Bucket, etc
2 PO ke KMI ada
Stand while splilting (Waste Oil, Steel, etc)
To do disassemble
Work Bench + Vice Grip Min 1 ada Webbing sling (2 ton) (12 m, 6 m, 3 m) 2 each to pull and to lift tractor
and re-assemble
Required Tools / Tools yang harus dimiliki Measurement Tools / Alat ukur yang dimiliki
Nama Gambar Jumlah Keterangan Aktual Nama Gambar Jumlah Keteranqan Aktual
ada with
nonius scale
To check thè tightening 0.05
Torque Wrench 1 torque ada, 25 - 135 Nm Vernier Caliper 1 To measure dimension
Capacity : 25 -150 Nm
Clutch Center Tool 1 To assemble clutch disc PO ke KMI Micrometer Outside 1 To measure dimension ada
To make
Radiator Tester 1 troubleshooting for PO ke KMI Bore Gauge 1 To measure gap dimension PO ke KMI
engine
To make easy
Adapter 7 1 measure Engine oil PO ke KMI Multimeter 1 To check connection electricity, voltage, etc ada
pressure
1 To pulì pin or tracker pin PO ke KMI Nozzle Tester 1 To test injection pressure and spray pattern of PO ke KMI
Sliding Hammer
nozzle
Notes :
For others Special Tools, please see WSM of M9540 Tractor / Untuk Alat Khusus lainnya, silakan lihat WSM ofM9540 Tractor