Professional Documents
Culture Documents
v002: 26/05/16
Please read carefully before use and retain for future reference.
Handle
PARTS
Screw
Base x1
Lower handle section x1 Handle Cord hook
Hand grip x1
Microfibre pad x2 Handle
Connecctor
Felt Polishing pad x2
Cleaning pad x2
Handle Cord hook
Cloth bonnet x2 Release Handle
On/Off Connecctor
Base
ASSEMBLY OPERATION
• Attach the lower handle section to the base using the • Choose the desired pads and attach ensuring the plastic clips
pre-fitted screw. are secure.
• Attach the upper handle section to the lower handle section • Apply a small amount of a suitable floor/carpet stain remover to
ensuring the locking pin clicks securely into position. stubborn stains to assist removal.
• Attach the hand grip to the upper handle section using the • Press down on the handle release on the right side of the base
pre-fitted screw. unit and release the handle by pulling towards you. This will
• Ensure all fixings are tightened fully before use. activate the scrubbing brushes.
• When finished, raise the handle and lock into the upright
position. This will turn the machine off.
See table below for recommendations on when to use each set of cleaning pads:
Pad Use
Microfibre pad For cleaning tiled/wooden floors
Felt Polishing pad For polishing tiled/wooden floors
Cleaning pad Use on stubborn stains and on concrete floors
Scrubbing brushes (without pads) Use on carpets to agitate stains and to clean grout between tiles
Cloth bonnet For use on carpets (attach over felt polishing pad)
CLEANING
WARNING
PACKAGING