Professional Documents
Culture Documents
1.2. Relevant identified uses of the substance or mixture and uses advised against
Supplier
Gulf Oil Lubricants India Ltd., IN Centre, 49/50, MIDC, 12th Road, Andheri (East),
Mumbai -400 093
+ 91 22 66487777
Signal Word
None
Hazard Statements
EUH208 - Calcium long chain alkaryl sulphonate May produce an allergic reaction.
_____________________________________________________________________________________________
Page 1 / 10
02140/15W-40/1 - BB Genuine Engine Oil, SAE 15W-40 Revision Date: 09-14-2016
_____________________________________________________________________________________________
Additional information
Product containing mineral oil with less than 3% DMSO extract as measured by IP 346
See Section 15 for additional information on base oils.
** Substances for which there are Community workplace exposure limits
General advice May produce an allergic reaction. When symptoms persist or in all cases of doubt seek
medical advice.
Skin contact Wash off immediately with plenty of water for at least 15 minutes. Remove and wash
contaminated clothing before re-use. May cause an allergic skin reaction. If symptoms
persist, call a physician.
Eye contact Rinse thoroughly with plenty of water, also under the eyelids. Keep eye wide open while
rinsing.
Ingestion Clean mouth with water. Drink plenty of water. Do not induce vomiting without medical
advice.
Protection of First-aiders Use personal protective equipment. Avoid contact with skin, eyes and clothing.
4.2. Most important symptoms and effects, both acute and delayed
_____________________________________________________________________________________________
Page 2 / 10
02140/15W-40/1 - BB Genuine Engine Oil, SAE 15W-40 Revision Date: 09-14-2016
_____________________________________________________________________________________________
or foam, Water spray or fog, Cool containers / tanks with water spray
Special Hazard
Thermal decomposition can lead to release of irritating gases and vapors. Carbon monoxide, carbon dioxide and unburned
hydrocarbons (smoke). In the event of fire and/or explosion do not breathe fumes. This material creates a fire hazard because it
floats on water. Combustible material.
Remove all sources of ignition. Ensure adequate ventilation. Use personal protective equipment. Avoid contact with skin, eyes and
clothing.
Prevent further leakage or spillage if safe to do so. Do not flush into surface water or sanitary sewer system.
Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust). Dike to collect large liquid spills.
Ensure adequate ventilation. Do not eat, drink or smoke when using this product. Handle in accordance with good industrial
hygiene and safety practice. Wear personal protective equipment. Avoid contact with skin, eyes and clothing. Remove and wash
contaminated clothing before re-use.
_____________________________________________________________________________________________
Page 3 / 10
02140/15W-40/1 - BB Genuine Engine Oil, SAE 15W-40 Revision Date: 09-14-2016
_____________________________________________________________________________________________
Incompatible Materials
Oxidizing agents
_____________________________________________________________________________________________
Page 4 / 10
02140/15W-40/1 - BB Genuine Engine Oil, SAE 15W-40 Revision Date: 09-14-2016
_____________________________________________________________________________________________
Hygiene measures Wear personal protective equipment. Avoid contact with skin, eyes and clothing. Remove
and wash contaminated clothing before re-use. Handle in accordance with good industrial
hygiene and safety practice.
_____________________________________________________________________________________________
Page 5 / 10
02140/15W-40/1 - BB Genuine Engine Oil, SAE 15W-40 Revision Date: 09-14-2016
_____________________________________________________________________________________________
Vapor pressure No information available
Vapor density No information available
Relative density 0.8873 @15°C
Solubility(ies) Insoluble in water
Partition coefficient: n-octanol/water Not Applicable
Autoignition temperature No information available
Decomposition temperature No information available
Viscosity, kinematic 109.7 cSt @ 40 °C ASTM D 445
Explosive properties Not Applicable
Oxidizing Properties Not Applicable
Heat, flames and sparks, Keep away from open flames, hot surfaces and sources of ignition
Oxidizing agents
Incomplete combustion and thermolysis produces potentially toxic gases such as carbon monoxide and carbon dioxide.
Skin contact Repeated or prolonged skin contact may cause allergic reactions with susceptible persons
_____________________________________________________________________________________________
Page 6 / 10
02140/15W-40/1 - BB Genuine Engine Oil, SAE 15W-40 Revision Date: 09-14-2016
_____________________________________________________________________________________________
Product does not present an acute toxicity hazard based on known information.
Chemical Name LD50 Oral (Rat) LD50 Dermal (Rat/Rabbit) LC50 Inhalation
Highly refined base oil (Viscosity >2000 mg/kg >2000 mg/kg
>20.5 cSt @40°C)
Skin corrosion/irritation Based on available data, the classification criteria are not met.
Serious eye damage/eye irritation Based on available data, the classification criteria are not met.
Sensitization
Respiratory Sensitization Based on available data, the classification criteria are not met.
Skin sensitization May cause an allergic skin reaction.
Germ Cell Mutagenicity Based on available data, the classification criteria are not met.
Carcinogenicity Based on available data, the classification criteria are not met.
Reproductive toxicity Based on available data, the classification criteria are not met.
Specific target organ systemic Based on available data, the classification criteria are not met
toxicity (single exposure)
Specific target organ systemic Based on available data, the classification criteria are not met
toxicity (repeated exposure)
Aspiration hazard Based on available data, the classification criteria are not met.
The product is not readily biodegradable, but it can be degraded by micro-organisms, it is regarded as being inherently
biodegradable.
No information available
This preparation contains no substance considered to be persistent, bioaccumulating nor toxic (PBT). This preparation contains no
_____________________________________________________________________________________________
Page 7 / 10
02140/15W-40/1 - BB Genuine Engine Oil, SAE 15W-40 Revision Date: 09-14-2016
_____________________________________________________________________________________________
substance considered to be very persistent nor very bioaccumulating (vPvB).
None known
Contaminated packaging Empty containers should be taken to an approved waste handling site for recycling or
disposal. Observe all label precautions until container is cleaned, reconditioned or
destroyed.
Other Data According to the European Waste Catalogue, Waste Codes are not product specific, but
application specific. Waste codes should be assigned by the user based on the application
for which the product was used.
Not regulated
Not regulated
Not regulated
Not regulated
None
None
14.7. Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code
Not applicable
_____________________________________________________________________________________________
Page 8 / 10
02140/15W-40/1 - BB Genuine Engine Oil, SAE 15W-40 Revision Date: 09-14-2016
_____________________________________________________________________________________________
ADN Not regulated
The Classification, Labeling and Packaging of Substances and Mixtures (CLP) Regulation (EC 1272/2008)
Registration, Evaluation, Authorization, and Restriction of Chemicals (REACh) Regulation (EC 1907/2006)
The highly refined base oil (Viscosity >20.5 cSt @40°C) contains one or more substance with the following CAS/EC
numbers/REACH registration numbers:
No information available
_____________________________________________________________________________________________
Page 9 / 10
02140/15W-40/1 - BB Genuine Engine Oil, SAE 15W-40 Revision Date: 09-14-2016
_____________________________________________________________________________________________
Aquatic Chronic - Chronic Aquatic Toxicity
Eye Dam. - Eye Damage
Eye Irrit. - Eye Irritation
Skin Corr. - Skin Corrosion
Skin Irrit. - Skin Irritation
Skin Sens. - Skin Sensitizer
Resp. Sens. - Respiratory Sensitizer
STOT SE - Specific target organ systemic toxicity (Single exposure)
STOT RE - Specific target organ systemic toxicity (repeated exposure)
VOC - Volatile organic compounds
•H224-Ex t
remel yfl
ammabl el iquidandvapor •H341-Suspect edofcausi nggenet i
cdef ects
•H225-Hi ghlyflammabl el iqui dandvapor •H350-Maycausecancer
•H226-Fl ammabl eliquidandvapor •H351-Suspect edofcausi ngcancer
•H270-Maycauseori ntensi fyf i
re;ox i
dizer •H360-Maydamagef ert
il
ityort heunbor nchi l
d
•H271-Maycausef i
reorex plosion;strongoxi
dizer •H361-Suspect edofdamagi ngf er t
il
it
yort heunbor nchil
d
•H272-Mayi ntensifyf i
re;ox idizer •H362-Maycausehar mt obr east -fedchi ldren
•H290-Maybecor r
osi vet omet als •H370-Causesdamaget oor gans
•H300-Fat alifswallowed •H371-Maycausedamaget oor gans
•H301-Tox icifswal l
owed •H372-Causesdamaget oor ganst hroughpr olongedorr epeated
•H302-Har mf ulifswal l
owed exposure
•H304-Maybef at
alifswal lowedandent er
sai
rways •H373-Maycausedamaget oor ganst hroughpr olongedorr epeat
ed
•H310-Fat alincont actwi t
hski n exposure
•H311-Tox icincont actwi thski n •H400-Ver yt
ox i
ct oaquaticlif
e
•H312-Har mf ulincont actwi thski n •H410-Ver yt
ox i
ct oaquaticlif
ewi thlongl astingef f
ect
s
•H314-Causessever eski nbur nsandeyedamage •H411-Tox i
ctoaquat i
clifewi thlongl astingef fect s
•H315-Causesski nir r
it
at i
on •H412-Har mfultoaquaticlif
ewi thl ongl ast i
ngef fects
•H317-Maycauseanal l
er gicski nreacti
on •H413-Maycausel onglast i
nghar mfuleffectst oaquat i
clif
e
•H318-Causesser i
ouseyedamage •H360Df-Maydamaget heunbor nchi l
d.Suspect edofdamagi ngfert
il
i
ty
•H319-Causesser i
ouseyei rr
itati
on •H360D-Maydamaget heunbor nchi ld
•H330-Fat alifinhaled •H360FD-Maydamagef erti
l
ity.Maydamaget heunbor nchild
•H331-Tox icifinhaled •H360F-Maydamagef erti
lit
y
•H332-Har mf ulifi
nhal ed •H361d-Suspect edofdamagi ngt heunbor nchi l
d
•H334-Maycauseal lergyorast hmasympt omsorbr eat
hingdi
ff
icul
ti
es •H361f d-Suspect edofdamagi ngf ertil
i
ty.Suspect edofdamagi ngthe
if inhaled unborn child
•H335-Maycauser espi rator yirrit
ati
on •H361f-Suspect edofdamagi ngf erti
li
ty
•H336-Maycausedr owsi nessordi zzi
ness •EUH066-Repeat edexposur emaycauseski ndr ynessorcr acki
ng
•H340-Maycausegenet i
cdef ect s •EUH210-Saf etydatasheetavai l
abl eonr equest
•EUH208-Maypr oduceanal lergicr eaction
Exposure scenario
No information available
Revision Note
Disclaimer
The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the
date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage,
transportation, disposal and release and is not to be considered a warranty or quality specification. The information
relates only to the specific material designated and may not be valid for such material used in combination with any other
materials or in any process, unless specified in the text.
_____________________________________________________________________________________________
Page 10 / 10