You are on page 1of 5

introduction: paraphrase:

2.overview
3. body 1

The line graph reveals aqua usage in UK over a


intro

period of 7 years .
overall :Overall, it clear that the water which was used
by population of UK increased between 2000 and 2007
By contrast , It is interesting to note that the amount
of water consumed by people of this country
fluctuated over the same period of shown.
Looking at the line graph in more detail, the need for water
by its users in mentioned country stood at 40.000 tones in
2000. However ( Di gəl ki ) there was a dramatic rise in the
amount of water used by UK citizens over the following 3
years reaching 60.000 tones. Interestingly, this trend
remained stable during 12 months. Subsequently ( sirasiyla)
these figures of water consumption were then replaced with
fluctuation throughout (sru`:aut) the next 2 years which
later followed by slight decrease in 2007. Finally , the usage
of water in this country suddenly escalated starting from
current year .
It is clear that there are six main stages in the manufacture of brick .In
particular ,the process commences with(başlamaq) initial collection of
building materials and ends up with delivery to the general
public.

At the beginning of the process, clay is dug from the ground. The clay is put
through a metal grid, and it passes onto a roller where it is mixed with sand
and water. After that, the clay can
be shaped into bricks in two ways: either it is put in a mould, or a wire cutter
is used.

At the fourth stage in the process, the clay bricks are placed in a drying oven
for one to two
days. Next, the bricks are heated in a kiln at a moderate temperature (200 -
900 degrees
Celsius) and then at a high temperature (up to 1300 degrees), before spending
two to three
days in a cooling chamber. Finally, the finished bricks are packaged and
delivered.
The mixed graph compares the proportion of average monthly precipitation( RAIN) as
well as temperature in one of the regions of East Africa over a period of 12 months.
Overall, it is clear that the level of rainfall and temperature hovered between January
and December. By contrast, it is interesting to note that the peak values for rainfall were
recorded in April, while the highest figures for temperature were observed in March.
Looking at the line and bar graph in more detail, the figure for temperature stood at 22
C, compared to 20millimetres for precipitation in January. Over the following two
months the number for temperature and rainfall surged markedly, making up 24 C in
March and 275 millimeters in April accordingly. In contrast with this, the proportion of
temperature experienced a gradual decline, dipping to its lowest point at 20.5 C in July.
The ratio of precipitation showed the similar trend and plummeted to 5 millimeters in
the mentioned month.
It could be explained by the fact that the degree of temperature went up substantially,
comprising 23.5 C in October before sudden fall to 21.5 C at the end of the year.
Meanwhile, the ratio of rain jumped noticeably to 125 millimeters in October, where it
remained almost constant for a period before decline and accounting for 50 millimeters
in December.

You might also like