Professional Documents
Culture Documents
Cerrar SIS
Pantalla anterior
Producto: EXCAVATOR
Modelo: NO SE HA ESCOGIDO NINGUN EQUIPO
Configuración: NO SE HA ESCOGIDO NINGUN EQUIPO
Pruebas y Ajustes
320 GC, 320 and 323 Excavators Tool Control System
Número de medio -M0081160-00 Fecha de publicación -01/10/2017 Fecha de actualización -06/10/2017
i07026858
Introduction
Use the following procedure to calibrate the joysticks, thumbwheels, travel pedals, and attachment
pedals.
Machine Preparation
Illustration 1 g06181120
1. Position the machine on level ground in the service position. Refer to Illustration 1.
Calibration Procedure
Monitor Procedure
Table 1
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisw... 9/06/2023
(M0085277 - null) - null Page 2 of 4
Illustration 2 g06241464
6. If the calibration was successful and no errors occurred, the display will indicate the
calibration is complete.
Note: The "Error" screen will be displayed on the monitor if an error occurs. The process of
the calibration will not be saved and the process must be restarted.
ET Procedure
Table 2
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisw... 9/06/2023
(M0085277 - null) - null Page 3 of 4
5. Select "Start".
Test Procedure
Use the following procedure to verify the joystick calibration.
Note: The hydraulic activation lever should be in the LOCKED position during the test
procedure.
Illustration 3 g06241477
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisw... 9/06/2023
(M0085277 - null) - null Page 4 of 4
4. Verify that the joysticks read 0% when all the control levers are in the NEUTRAL position.
5. Move the joystick to the full BOOM RAISE position and verify that the "Boom Lever
Position" reading is 99 to 100%.
Note: Verify that the "Boom Lever Position" reading immediately reduces from 100% when
coming off end stop and has a smooth transition to 0%.
7. Move the joystick to the full BOOM LOWER position and verify that the "Boom Lever
Position" reading is -99 to -100%.
Note: Verify that the "Boom Lever Position" reading immediately increases from -100%
when coming off end stop and has a smooth transition to 0%.
Note: If the joystick function does not meet the test procedure specifications, then perform
the calibration procedure again.
10. Repeat the test procedure for all functions within "Operator Input - Travel", "Operator Input
- Tool", and "Operator Input - Pedal/Lever".
Copyright 1993 - 2023 Caterpillar Inc. Fri Jun 9 20:03:57 EST 2023
Todos los derechos reservados.
Red privada para licenciados del SIS.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisw... 9/06/2023