You are on page 1of 2

CERTIFICATE OF ANALYSIS

PT. AVODA ULTIMA BERSIH


Hotline : 0812 1180 4805
Website : www.avodaultimate.com
Date COA issued : 19/03/2020

Product Name : Avoda Ultimate Poinsetta


Letter Version : 01/01/2020 – 31/12/2022
Date manufacture : 06/03/2020
Best Before : 24 months after cap is open

 Appearance : liquid
 Cl2 aktif : 0.0 %
 Colour : light yellow
 Total anti bacteria : 3.1 % min
 Fragrance : flower
 pH ( 2 % solution ) : 6-7

Surabaya, 19 Maret 2020


QC Department Manager

PT. DHARMAPALA USAHA SUKSES


Validate :
19/03/2020 – 19/06/2020

PT. Avoda Ultima Bersih


Jakarta-Bandung-Semarang-Yogyakarta-Surabaya-Denpasar-Makassar-Balikpapan
Declaration of Food Contact Compliance
When leaving our factory, has the following compliance status with the below mentioned
regulations on food contact plastics and other materials

AVD Poinsetta is a quaternary ammonium compound

1 FOOD CONTACT APPLICATIONS

1.1 EU and Member States


COMMISSION REGULATION (EU) No. 10/2011 of 14 January 2011, as amended by
Regulations (EU) No. 321/2011, 1282/2011, 1183/2012, 202/2014 and 2015/174, on plastic
materials and articles intended to come into contact with food, which has repealed with
effect
of 01 May 2011 the Directive 2002/72/EC, as amended by the Directives 2004/1/EC,
2004/19/EC, 2005/79/EC, 2007/19/EC, 2008/39/EC, 2011/8/EU and Regulation (EC) No.
975/2009:
Didecyldimethylammonium chloride: Not listed
Ethanol is listed on Annex I below Ref. No. 16780/52800 / FCM substance No. 113 and
approved as monomer/additive without a restriction.
2-Propanol is listed on Annex I below Ref. No. 23830/81882 / FCM substance No. 118 and
approved as monomer/additive without a restriction.
Ethylene glycol: listed on Annex I below Ref. No. 16990/53650 / FCM substance No. 227
and
approved as monomer/additive with the restriction of SML(T) = 30 mg/kg.
Diethylene glycol: listed on Annex I below Ref. No. 13326/15760/47680 / FCM substance
No.
263 and approved as monomer/additive with the restriction of SML(T) = 30 mg/kg.
In general, the final plastic material should be in compliance with the relevant European
regulations (Regulation 1935/2004, Directives 82/711/EEC, 85/572/EEC, as amended,
Regulations 10/2011 and 2023/2006).

Surabaya, 19 Maret 2020


QC Department Manager
PT. DHARMAPALA USAHA SUKSES
Validate :
19/03/2020 – 19/06/2020

PT. Avoda Ultima Bersih


Jakarta-Bandung-Semarang-Yogyakarta-Surabaya-Denpasar-Makassar-Balikpapan

You might also like