Professional Documents
Culture Documents
Series
General Information
Automatic Fire Alarm Warden Station Series telephones are compatible with the Digital Voice Command (DVC) and
DAL (digital audio loop) devices that support FFT risers.
The series has a handset with a push-to-talk switch, a hearing aid compatible speaker, and an indicator which illuminates
when the warden station is connected to the master telephone station. Up to seven handsets (including the master handset)
may be operated simultaneously.
AFAWSphn.wmf
AFAWSbg.wmf
AFAWSacp.wmf
AFAWbkbx1.wmf
Tempered
Glass
Armored Cable Coiled Cord Backbox
Hammer
Telephone Chassis Breakglass Kit
AFAWSfr3.wmf
AFAWSfr4.wmf
AFAWSfr1.wmf
AFAWSfr2.wmf
System Wiring
Max. riser wiring resistance is 50 ohms, 10,000 ft. (3048 m) max. wiring distance at 14AWG.
System wiring for telephones with either coiled cord or armored cable handsets must not be connected to outside wiring or
run in the same conduit or cable tray as power or cable TV lines.
Assembly of Units with Coiled Cord Handsets
The following assembly steps are for telephones with coiled cord handsets. These steps must be accomplished once the
enclosure has been mounted and the system wiring is in place (refer to Figure 2).
1. Attach system wiring to the terminal strip on the telephone chassis assembly.
2. Install 6-32 nut in backbox. Do not tighten.
3. Install telephone chassis assembly in backbox.
4. Install trim ring on backbox with 6-32 wing nuts. Do not tighten.
5. Install door assembly. Tighten wing nuts.
Assembly of Units with Armored Cable Handsets
The following assembly steps are for telephones with armored cable handsets. These steps must be accomplished once
the enclosure has been mounted and the system wiring is in place.
1. Attach system wiring to the terminal strip on the telephone chassis assembly.
2. Install 6-32 nut in backbox. Do not tighten.
3. Insert armored cable end into slot on top of telephone chassis assembly.
4. Install telephone chassis assembly in backbox.
5. Install trim ring on backbox with 6-32 wing nuts. Do not tighten.
6. Install door assembly. Tighten wing nuts.
To FFT Riser on
Digital Voice
Command or digital
audio amplifier.
From panel or last
device on SLC
BLACK
BLACK
RED
To next device on
telephone circuit, To panel or next
3.9k EOL device on SLC
resistor, or SLC Telephone
4-wire return Form C Control Module*
Dry Contact
(1A 30 VRMS)
BLACK
BLACK
COM
ON HOOK
OFF HOOK
RING
AUX SW
AFAWS Telephone Connections
Figure 2 AFAWS Telephone to SLC Telephone Control Module and FFT Riser
Form C
BLACK
RED
Dry Contact
(1A 30 VRMS)
TIP
COM
ON HOOK
OFF HOOK
RING
TIP OUT
RING OUT
+ - SHLD + - SHLD
COM
ON HOOK
OFF HOOK
RING
TIP OUT
RING OUT
AUX SW
AFAWS Telephone Connections
Figure 4 Telephone Direct to FFT Riser on XPIQ