Professional Documents
Culture Documents
50
L A B 4 . 5 0 D E H Y D R AT O R
F O R W AV E G U I D E S A N D C O A X I A L C A B L E S
key features
output pressure programmable up to 50 kPa
flow rate up to 300 l/h
dew point better than -45 °C
two pumps and two drying chambers running alternatively
continuous duty and automatic operation
drying chambers automatic regeneration
microprocessor control and monitoring with digital display
low/high pressure, high humidity, power and system failures alarms
local and remote alarm signaling
optional remote control through SNMP protocol and WEB browser or
through serial link
optional digital flowmeter for air flow measurement
output pressure, hour meter, alarms readout
low power consumption and low acoustic noise
wide-range power supply: both 110-240 VAC 50/60 Hz and 48/60 VDC
always available
high reliability and long life
mounting flexibility: wall, floor, 19” and ETSI N3 racks
description
The LAB4.50 dehydrator provides continuous dry air The following devices are available on the front panel:
flow up to 300 l/h with a dew point better than monitoring digital display
function keyboard to scroll and modify settings
-45°C. Output pressure can be set in the range from
power on and alarms LED
10 kPa to 50 kPa. on/off outlet valves
The LAB4.50 achieves reduced mechanical wear and Output air pressure, hour meter, active alarm
noise and therefore a long lifetime by output pressure messages, output pressure setting and alarm
thresholds are available on the digital display.
measurement, microprocessor control and pump
The basic version has low pressure, high pressure,
speed regulation. Pumps speed control avoids
high humidity, power and system failures alarms. The
mechanical pressure regulators eliminating alarms are remotely signaled by one SPDT relay.
undesirable pressure losses and a worse response to
As option are available:
plant air flow regulation. remote control through SNMP protocol and HTTP
WEB browser by an Ethernet interface,
Two drying chambers contain the desiccant and dry
remote control by a RS485/RS422 or R232 serial
airstream by adsorption process. The chambers link,
operate on alternate cycles so while the first chamber digital flowmeter with data showed on the display
dries, the second one regenerates the desiccant by On the rear panel are available the AC and DC power
supply connectors, the connector for remote alarm
heating and backwashing with a small reverse dry air
and the optional RJ45 connector for Ethernet interface
flow.
or D-Sub 9 pins for serial link.
This technology reduces overall power consumption. The LAB4.50 always includes wall, floor, 19” and ETSI
N3 rack mountings.
pneumatic scheme
DRYING CHAMBER
HEATER
PUMP
HUMIDITY PROBE
RELIEF VALVE
electrical specifications
Power supply : both 110-240 VAC 50/60 Hz and 48/60 VDC always
available
Power consumption
Average : < AC: 60 VA, DC: 35 W
Max during regeneration phase : < AC: 100 VA, DC: 60 W
The equipment illustrated are fully equipped versions. CIBRED SUD reserves the right to modify without notice characteristics and data supplied herein.
Via Catania 2 00041 Albano Laziale Loc. Pavona (RM) - Italy
T el. +3 9 0 6 93 4 40 0 9 Fax + 3 9 0 69 3 44 0 35
ww w.c i bre d .c om e - m ail : c i bre d @c i bre d .c om
C16600-E.DS0 DEL 03.21