Professional Documents
Culture Documents
Draft saved
AENG 418 Aircraft Production, Maintenance, Planning and Control MIDTERM EXAM
Please follow the following instructions before you start answering the questions below:
(I). For multiple choice-type questions, click the choice of your best answer.
(II). For checkbox-type questions, check the boxes of all possible answers.
malfunctioning.
Refueler
ASU
GPU
Tractor
Clear selection
An aviation industry term that refers to the variety of services performed on 2 points
Ground Support
Ramp Service
Ground Handling
Line Maintenance
Clear selection
Dispatches the aircraft, maintains communication with the rest of the airline 2 points
Ramp Service
Field Operations
Line Maintenance
Passenger Service
Clear selection
Hard-Time, On-Condition, and Condition Monitoring fall under 2 points
MSG - 1 Tasks
Task-Oriented Maintenance
MSG - 3 Tasks
Process-Oriented Maintenance
Clear selection
This contains the basic information on the operation and maintenance of 2 points
the aircraft and its equipment
SRM
AMM
IPC
WDM
Clear selection
An aircraft's MPD consists of information from the following [Check all that 6 points
apply]
FIM
MRBR
AMM
CMR
AL
SRM
AD
Manufacturer
Operator/ Airline
Clear selection
Who's the one responsible for creating the aircraft's CMR? 2 points
Manufacturer
Operator/ Airline
Clear selection
Who's the one responsible for creating the aircraft's CAMP? 2 points
Operator/ Airline
Manufacturer
Clear selection
Who's the one responsible for approving the aircraft's CAMP? 2 points
Operator/ Airline
Manufacturer
Clear selection
Who's the one responsible for approving the aircraft's MPD? 2 points
Manufacturer
Operator/ Airline
Clear selection
EASA
ICAO
ATA
FAA
Clear selection
This check maintenance is typically done at a hangar and can take a 2 points
Clear selection
Up to 6,000 maintenance hours are typically needed for these checks 2 points
Clear selection
After a couple of C checks, the airlines usually buy a new aircraft instead of 2 points
True
False
Clear selection
You can get the part numbers of every component here. 2 points
SRM
AMM
WDM
IPC
Clear selection
Manufacturer
Owner/Operator
Clear selection
Who is responsible in creating the aircraft's AD? 2 points
Owner/Operator
Manufacturer
Clear selection
Owner/Operator
Manufacturer
Clear selection
False
True
Clear selection
What does IPC mean? 2 points
The first three sets of two-digit codes in the numbering system serve as 2 points
Page Blocks
ATA Chapter
Clear selection
The number 56-10-22-003 most likely talks about what? 2 points
Clear selection
Clear selection
Water/Waste
Servicing
Clear selection
ATA Chapter 38 talks about... 2 points
Fuel
Servicing
Water/Waste
Clear selection
The Three-digit block near the end of a typical page numbering system 2 points
refers to
ATA Chapter
Section
Subsection
Page blocks
Clear selection
This Chapter talks about the dimensions of the aircraft as well as the 2 points
ATA Chapter 6
ATA Chapter 12
ATA Chapter 9
ATA Chapter 10
Clear selection
Which of these page blocks would servicing take place? 2 points
212
315
755
145
Clear selection
126
415
317
555
Clear selection
Information about the aircraft's Fuel System is found on what chapter? 2 points
ATA 27
ATA 80
ATA 71
ATA 28
Clear selection
Forms