This document provides instructions for a laboratory session on basic electronics at the University of Ghana. Students are asked to: [1] Simulate a circuit diagram in Proteus software to find the current values and voltage, [2] Implement the same circuit on a breadboard to measure currents and voltage, [3] Compare the results from the simulation and hardware implementation.
This document provides instructions for a laboratory session on basic electronics at the University of Ghana. Students are asked to: [1] Simulate a circuit diagram in Proteus software to find the current values and voltage, [2] Implement the same circuit on a breadboard to measure currents and voltage, [3] Compare the results from the simulation and hardware implementation.
This document provides instructions for a laboratory session on basic electronics at the University of Ghana. Students are asked to: [1] Simulate a circuit diagram in Proteus software to find the current values and voltage, [2] Implement the same circuit on a breadboard to measure currents and voltage, [3] Compare the results from the simulation and hardware implementation.
School of Engineering Sciences Department of Computer Engineering Second Semester 2022/2023 Academic Year SENG 108 Basic Electronics (3 Credits) LABORATORY SESSION 4 – 20 marks
You are to use figure 1 to answer the questions below.
8V
Figure 1
1. Implement the circuit in Figure 1 in Proteus
a. Find the IC, IE and IB in Figure 1using the Proteus software. b. Find VCE from Figure 1 using the equation: 2. Implement the circuits in Figure 1 on a breadboard in the laboratory. a. Find the IC, IE and IB in Figure 1using the breadboard. b. Find VCE from Figure 1 using the equation:
3. Compare your results in Question 1 and Question 2