Professional Documents
Culture Documents
SMP of ABB MP100 For Tundish in MC#1&2
SMP of ABB MP100 For Tundish in MC#1&2
MC#1&2 IN CCP
SAFETY POINTS :
2. Press <SEND> key. The display shown ‘Sn _ _’. ‘Sn’ represents the scale number. Select
the scale number 1 for car-1 or 2 for car-2 for respective TUNDISH Weighing System in
dotted line. Press the <SEND> key to confirm.
3. Press the key <P> for selection of program function and type the number 31, for
selection of calibration with a TEST WEIGHT.
4. Press the <SEND> key. The display shows PAUSE for approximately 6 seconds. The
display then shows 6 dotted lines.
5. Load the Tundish Car with TEST WEIGHT. Note down the values displayed in the LDU
and COPSV monitor for car in loaded condition.
10. Unload the TEST WEIGHT and Note down the values displayed in the LDU and COPSV
monitor for empty car.
11. Put the ‘CODE LOCK’ key of Processor Board is in ‘BLOCK’ position