This document provides instructions for diagnosing, removing, and installing a generator and regulator on a 2008.50 Ford Mondeo with either a 2.0L or 2.3L Duratec-HE engine. The diagnostic section refers technicians to the general charging system information. Removal involves loosening accessory drive belt tension, disconnecting battery ground cable, and removing mounting bolts. Installation is the reverse of removal, taking care not to damage wiring harnesses and properly torquing all fasteners.
This document provides instructions for diagnosing, removing, and installing a generator and regulator on a 2008.50 Ford Mondeo with either a 2.0L or 2.3L Duratec-HE engine. The diagnostic section refers technicians to the general charging system information. Removal involves loosening accessory drive belt tension, disconnecting battery ground cable, and removing mounting bolts. Installation is the reverse of removal, taking care not to damage wiring harnesses and properly torquing all fasteners.
This document provides instructions for diagnosing, removing, and installing a generator and regulator on a 2008.50 Ford Mondeo with either a 2.0L or 2.3L Duratec-HE engine. The diagnostic section refers technicians to the general charging system information. Removal involves loosening accessory drive belt tension, disconnecting battery ground cable, and removing mounting bolts. Installation is the reverse of removal, taking care not to damage wiring harnesses and properly torquing all fasteners.
CAUTION: Make sure that the ignition key All vehicles
is removed. 3. Refer to: Accessory Drive Belt (303-05 NOTE: Removal steps in this procedure may Accessory Drive - 2.0L Duratec-HE (MI4)/2.3L contain installation details. Duratec-HE (MI4), Removal and Installation). 4. CAUTION: Take extra care not to Vehicles with 2.0L engine damage the wiring harnesses. 1. Torque: 15 Nm
E86476
Vehicles with 2.3L engine
2.
E70352
E87882
2008.50 Mondeo 1/2009 G954606en
414-02-4 Generator and Regulator 414-02-4 REMOVAL AND INSTALLATION 5. 1. Torque: 25 Nm 2. Torque: 47 Nm
E70353
6. NOTE: The following step is only required if a
stud is loosened when the nut is removed. Torque: 47 Nm
x2
E73997
Installation 1. To install, reverse the removal procedure.