7773, 1118 AM
17773, 1118 AM
See
AGE
WideGap 200
Wide-gap Plate heat exchanger
Applications
‘Wide-gap plate heat exchanger for general heating, cooling
and heat recovery of media contaringfores and coarse part-
‘les. In action the wide-gap channels are stabi for highly
‘wecous tide,
Standard design
“The plate heal exchangor consists ofa pack of corrugated
‘metal pates ith portnoie forthe passage of the two fulds
bbetwoen which heat transi vil take place
“The plate pack is assembled betwean a fixed fame plate and
a movable pressure plate and compressed by tightening
bolts. The plates are fed with a gasket, which seas the
interplate channel and cect the fui into alternate channel.
“The number of plates is determinad by the flow rat,
pyscal properties ofthe tis, pressure crop and tempera
‘ure program. The plate corrugations promote uid turbulence
and suport the plates against ciferetil pressure, The number
‘of plates is determined by the tow rat, the physical
properties ofthe fds, the preseure drop and the temporature
rogram. The plate corrugations promote hid turbulence
anc support the ptes against cifeential prassur,
“The Wide-gap plates feature coarse cornugations with a
‘108s section width of anpraximately 11 mm (5/12") between
‘the plates, and have fat non-comugated porthoes forthe
product channes. The Wido-gap plate haat exchanger can
be used in two configurations, WNide-gap/Narow-gap end
Medium-gap/Mecum-cap,
“The frame plato and the pracsure plata are suspended fram
an upper carving bar and tecated by a tower guiding Dar,
bth of which are fed 1 @ suport column,
Connections ara located in the frame plato o iether or both
fuids meke more than 2 single pass within the unt n the
‘rame and pressure plates,
‘TYPICAL CAPACITIES
Liquid low rate
Up to 150ka/s (2268 pmo), depending on media,
prmitiec pressure drop and temperature program.
\Wideap 200
Plate types
\Wide-gap plates
Frame types
Fa
287773, 1118 AM
3