Professional Documents
Culture Documents
4
4
WANDPARTONECHAPTERTWOMAGNETICEFFECT
[1] Choose the correct answer in each of following:
[1] In the show circuit if change the variable resistance (T) from (R to 5R) "Then:
The magnitude of change of the reading voltmeter is …..
[a] Zero
[b] 2V P216 is 298
[c] 4V
[d] 5V
[2] In the show circuit as figure:
"The reading of ammeter at closed the switch (S) with of the following:
2 1
[1] The point (a) is …. [a] 2A [b] 3 A [c] 6 A
[2] The point (b) is ….
2 1
[a] 2A [b] 3 A [c] 6 A P297
[3] The point (c) is ….
2 1
[a] 2A [b] 3 A [c] 6 A
[3]Five (5) identical wires the resistance in each one of them 2Ω connected between
Two points (A and B), if connected two wires from same material of value of them
(2Ω) also by point's line: So:
The ratio between the total resistance between (A and B) before and after connected
Two wires is …………
7
[a] 5
3
[b] 5 P216
5
[c] 3
6
[d] 5
[4] The magnetic flux density increases at the center of a circular coil carrying an
Electric current by decreasing …..
[a] Cross-sectional area of the coil
[b] The number of the coil turns
[c] The current intensity in the coil
[d] The permeability of the coil core
[1]
[5] In the electric shown as the figure
The reading of voltmeter at the switch is open is (V) P273 No 13a
At the close switch becomes ……..
1
[a] V [b] 2V [c] 2 V [d] 3V
[6] In the figure the value of the resistance ( RV )
That to make the current in ( I 3=zero) is …..Ω P273 No 13 b
[a] 4 [b] 3
[c] 2 [d] 1
[7] In the electric circuit shown as drawing:
The value of shunt resistance ( R S) = …..Ω
[a] 8 [b] 9 [c] 10 P277 NO 40 B
[8]In the figure lamp has filament and rod (XY) P277 NO 40 B
What happens for three devices when
Moving the slider from (X) to (Y) ……
dX
Distance between each point and the wire ( d ) equals ……
Y
2 1 1 3
[a] 3 [b] 3 [c] 6 [d] 2
[19] Physical quantity equivalent resistance of wire from a certain material of length
(1m) and cross-sectional area of (1m2) at a certain temperature is ……..
[a] The electrical conductivity [b] The electrical resistivity
[c] The electrical resistance [d] The inductive reactance
[20] The current intensity result passing a quantity of electric charge (1C) through the
Cross-sectional of conductor in one second is …..
[a] Ampere [b] Coulomb [c] Volt
[21]The function of the concave of the two Poles of magnet in sensitive galvanometer
Is … [a] To provide a uniform radial magnetic field
[b] That ensures that angle of scale deflection is proportional to the passing current
[c] That the position of the plane coil is parallel to the magnetic lines
[d] That the magnetic torque is a maximum at any position
[e] All the previous
[22] Voltmeter of resistance (300Ω) and a maximum potential difference can be
Measured (V g) Then the multiplier resistance that can be to measure a maximum
Potential difference (10V g) is …..
[a] 3000Ω [b] 2700Ω [c] 300Ω [d] 270Ω
[4]
[23] The rule used to determine in each of the following:
[1] The direction of the magnetic field around a long wire carrying a d. c. is …….
[a] Ampere ring hand rule [b] Flemings left hand rule [c] Maxwell screw rule
[2] The direction of the magnetic force affecting a wire carrying current placed
Perpendicular to a magnetic field is ……..
[a] Ampere ring hand rule [b] Flemings left hand rule [c] Maxwell screw rule
[3] The magnetic polarity of a coil or a solenoid carrying d c is ….
[a] Ampere ring hand rule [b] Flemings left hand rule [c] Maxwell screw rule
[24] In the circuit shown as figure: What reading in each of the ammeters?
[a] The reading ammeter (A1) is …………. 3Ω 2Ω
[a] 1A [b] 2A [c] 3A A2
[b] The reading ammeter (A2) is …………. 6Ω 12V
[a] 1A [b] 2A [c] 3A A1
[25] The mathematical relation used to determine each of the following:
[1] The current intensity through the ohmmeter circuit, that provides a full-scale
Deflection is ……
V V V
[b] I = R + R + R +r [c] I = R
B B B
[a] I g = R + R + R +r
g h St g h St Equivalent + r
[2] The electric current intensity passing through a closed circuit is …..
V VB VB
[b] I = R + R + R +r [c] I = R
B
[a] I g = R + R + R +r
g h St g h St Equivalent + r
[26] As a current of intensity (I) passing through two parallel long wires, then on
Doubling the current intensity in both wires and decreasing the separating distance
To half, the mutual force increases to …..
[a] Double [b] four times [c] eight times
[27]Two Galvanometer are identical in each think except the number of turns of the
First (200turn) and resistance of its coil (20Ω) and the second of turns (300turn)
And its resistance (25Ω) connected in each of them with cell of (2V) and internal
θ1
Resistances (5Ω) then the ratio of have deflection is θ ……..
2
5 3 4 2
[a] 6 [b] 5 [c] 5 [d] 3
[28] In the previous equation the ratio between the sensitive current is …..
4 2 3 5
[a] 5 [b] 3 [c] 2 [d] 6
[29] In the previous equation the ratio between the sensitive voltages is …..
4 2 3 5
[a] 5 [b] 3 [c] 2 [d] 6
[5]
[30] Increasing of the electric resistance of a copper wire at certain temperature by
[a] Increasing length of wire [b] Decreasing sectional area of the wire [c] [a] and [b]
[31] Increasing the potential difference between the Poles of an electric cell in a close
Circuit by ………..
[a] Increasing the equivalent (external resistance in the circuit
[b] Decreasing the circuit current
[c] Decreasing the internal resistance [d] All the previous
[32]The zero position of a moving coil galvanometer is at the middle of its scale due to
[a] Depending on the direction of the current through the galvanometer coil, the
Pointer and the coil can deflect either clockwise or anticlockwise
[b] Depending on the magnitude of the current through the galvanometer coil, the
Pointer and the coil cannot deflect either clockwise or anticlockwise
[c] Depending on the variable of the current through the galvanometer coil, the
Pointer and the coil can deflect either clockwise or anticlockwise
[33] The ohmmeter use to measure …..
[a] The direct current intensity passing through circuit
[b] The potential difference between two poles of battery
[c] The non-known external resistance
[34] The shunt resistance use to ….
[a] It increases the range of measuring the current intensity
[b] Decreasing the resistance of the device, not to affect the intensity of measured
[c] Decreasing the sensitive of the device [d] All the previous
[35] A sensitive galvanometer is connected to a shunt (X) 0f 0.2Ω and then this shunt
Is replaced by another shunt (Y) 0f 0.02Ω with the same galvanometer:-
In which case, the ammeter can measure a higher range of current intensity? Why?
[a] The ammeter in the second case (0.02Ω), due to the shunt decrease the
Measuring range increases
[b] The ammeter in the first case (0.2Ω), due to the shunt decrease the measuring
Range decreases
[36]An ohmmeter whose circuit has a resistance of (3750Ω) and the maximum current
That can be passed through it is (400µA) then the value of the external resistance
That makes its pointer deflect to half of its scale = ………Ω
[a] 3750 [b] 7500 [c] 11250 [d] 1875
[37] When could the magnetic force affecting a wire carrying d c and placed within a
Magnetic field is a maximum as the wire is placed …….. to the field
[a] perpendicular [b] Parallel [c] Inclination by angle 45 °
[6]
[38] Use the given figure:
The ratio between the readings of the two voltmeters R R V2 V1 R
V1 2 1
V2
= ….. [a] 1
[b] 2 [c] 1
[39] In the given circuit:
Use Kirchhoff's laws "Then: P202
[a] The magnitude of current ( I 1) = …..
[a] 1A [b] 2A [c] 3A
[b] The consumed power through (3Ω) = …. [a] 3W [b] 12W [c] 27W
[40] The resistance of galvanometer is …………… its resistance after extending its
Rang of reading and being converted to an ammeter
[a] More than [b] less than [c] Equal to
[41]The magnetic flux density at the center of a circular ring of radius ( r) and carrying
Current of intensity (I) is … That at a distance (r) from a very long straight wire
Carrying current of intensity (3I) [a] More than [b] less than [c] Equal to
[2] Mention the physical quantity that measured by of the following and equivalent unit
The measure unit The physical quantity The equivalent measure unit
1- Kg m sec V
2 - 3 -1
2- Kg m2 sec-2V-1
3- Kg m2 sec-3A-1
4- Kg m2 sec-3A-2
5- Kg-1 m-3 sec2 A2
[3]Show without drawing
[1]"How to convert a micro-ammeter of coil resistance (250Ω) into an ohmmeter?
[2] The following table relates the reading of micro-ammeter of different external
Resistance value ( R X ) use the table to needed R X /Ω I/µA
Standard resistance added for the micro-ammeter 0 200
[3] Determine the e.m.f of the used source. 7500 100
Neglecting its internal resistance, also, using the same ∞ 0
Table finds out the value of the external resistance ( R X ) that provides a current of
In the micro-ammeter of (50µA)
[4] Mention the function of the standard resistance in the ohmmeter
[*]………………………………………………………………………………………………………………………………….
…………………………………………………………………………………………………………………………………
………………………………………………………………………………………………………………………………….
…………………………………………………………………………………………………………………………………
………………………………………………………………………………………………………………………………….
[7]