Professional Documents
Culture Documents
Strength of Materials Pre-Test
Strength of Materials Pre-Test
design stress
working stress
endurance limit
ultimate stress
yield stress
This is the maximum stress that will not cause failure when the force is reversed
indefinitely.*
1 point
ultimate stress
endurance limit
design stress
working stress
ultimate strength
yield strength
elastic limit
unit strain
It is the maximum stress that can be applied without permanent deformation of the test
specimen.*
1 point
unit strain
elastic limit
yield strength
ultimate strength
It is the maximum stress to which a test specimen may be subjected and still return to
its original length upon release of the load.*
1 point
elastic limit
ultimate strength
unit strain
yield strength
A steel tie rod on bridge must be made to withstand a pull of 5000 lbs. Find the diameter
of the rod assuming a factor of safety of 5 and ultimate stress of 64,000 lb/in^2.*
2 points
0.79 in
0.75 in
0.84 in
0.71 in
If the ultimate shear strength of a steel plate is 42,000 lb/in^2, what force is necessary
to punch a 0.75 in diameter hole in a 0.625 in thick plate?*
2 points
A link has load factor of 0.8, the surface factor is 0.92 and the endurance strength is
28000 psi. Compute the alternating stress of the link if it is subjected to a reversing load.
Assume a factor of safety of 3.
2 points
8150
10920
9333
7260
A steel wire 10m long hanging vertically supports a tensile load 2000 N. Neglecting the
weight of the wire, determine the required diameter if the stress is not to exceed 140
MPa. Assume E= 200 GPa.*
2 points
5.05 mm
6.0 mm
5.50 mm
4.26 mm
2.64 mm
A steel wire 10m long hanging vertically supports a tensile load 2000 N. Neglecting the
weight of the wire, determine the required diameter of deformation or if the the total
elongation is not to exceed 5mm. Assume E= 200 GPa.
2 points
4.26 mm
2.64 mm
5.05 mm
5.50 mm
6.0 mm