Section 5. TROUBLE-SHOOTING
A good maintenance ensures a good performance
Should troubles happen, take the adequate measures immediately.
‘The following table shows the causes of troubles tend to happen ordinarily
and the guide for counter-measure.
TROUBLES CAUSES: ‘MEASURES
No discharging or | 1. The pumpis not filled with | 1. Try priming again.
insufficient. water or water is
discharge insufficient.
[2. Rotation to the 1. Check the direction.
opposite direction.
8. Clogging of suction pipe | 3. Check inside of the suction
pipe. |
4, Clogging of impeller 4, Cheek inside of impeller.
J ————
5. Air leakage into pump 5. Check suction pipe
6. Low revolutions 6. Check with a revolution |
| meter.
Motor over-load 1. Impeller isin contact with | 1. Check the installation
pump easing. condition of pump and |
looseness of bearings,
Pump vibration 1. Disorder of shaft center 1. Check the shaft center _
| of pump and motor.
oteTROUBLES
‘CAUSES
MEASURES —
Pump vibration
2, Foreign things clog somewhere
in impeller
2 Check the inside
impeller
Rotating parts are in contact with
stationary part.
| 8. Check center and bend of
the shatt,
Leakage from
mechanical seal
‘Abnormal heat of
‘mechanical seal
1. Damage of defacement of sealing
surface
surface
|2. Foreign matters on the sealing
1. Remove the mechanical
seal to check the sealing
surface,
|. Packing is damaged.
"3. Check the packing.
4, Seales sticking to packings make
clearance between sealing surface
and shaft.
‘Dry running of pump
4, Remove the scale
completely by
disassembling
mechanical seal,
1. Stop the pump
operation
immediately.
Troubles of
ball bearings
1. Damage of balls or rolling surface
1. Replace the bail bearing
with new one
2. Excessive gap due to abnormal
2. ditto
8. Abnormal wear of retainer.
3. ditto