Professional Documents
Culture Documents
1, Brief introduction:
tested the kit okay,the kit remains the state when testing.The connectors
route the cables and connect the power supply from the right battery.
Why the RIGHT battery, check the voltage and rated current of the
battery,if any of the value is beyond the rated value of the controller, it
might works for a while,but it will not last for a longer time. So check the
Normally the most common error emerging is E07 on the display, its
because the controller needs to be fit with the motor. Turn on the power
supply, plug the two learning cables and the motor will be running at a
low speed. This is the learning process. Unplug the learning cables and
turn off the power supply and restart again. Keep the learning cables
Whats does the learning cables look like? All the connectors are plugged,
the two cables left unplugged and bundled together are the learning
1 motor
1 controller
1 throttle
1 display
1 front light
1 switch
1 PAS 12 poles
1 controller box
4, Attention:
Our controller is okay with 36v and 48v,same the display.If the battery’s
voltage and current is way beyond the controller.It will be cease working.
End