Professional Documents
Culture Documents
Installation
For operating systems starting from Windows® XP.
WARNING:
• BEFORE INSTALLING UNCERTIFIED USB DRIVERS IN OPERATING SYSTEMS
STARTING FROM WINDOWS 7, IT IS NECESSARY TO RESTART THE PC DISABLING THE
DRIVERS SIGNATURE REQUEST.
INSTALLATION PROCEDURE
1. Do not connect the instrument to the USB port until it is requested to.
2. Right-click with the mouse on the file autorun.exe of the software package and select Run
as administrator.
5. The program verifies the presence of the drivers inside the PC:
• If they are not present, the initial setup screen appears, press NEXT to proceed with the
installation.
• If they have already been installed, you are asked if you want to uninstall them.
1
6. The installation programme shows you the software licence agreement: in order to pro-
ceed, accept the terms of use and press NEXT:
7. The folder where drivers will be insalled is indicated in the installation window. Select IN-
STALL without making changes.
8. Wait for the program to install the files. At the end you get the windows that confirms the
correct installation of the drivers: press FINISH to close the installation program.
9. Connect the instrument to the USB port and switch it on: when Windows recognizes
the new device, a message appears in the lower right side of the screen indicating that a new
hardware has been found and the device driver installation is started. Wait for the message
confirming that the "TUSB3410" device driver installation has been completed.
2
10. The driver installation is finished: at any further connection the instrument will be automat-
ically recognized.
Notes:
Note 1. If the instrument is connected to the USB port before the installation of the driver:
• In Windows XP systems, “New hardware installation wizard ” window appears.
• In the systems starting from Windows Vista an installation error appears in the “Device Man-
ager ”.
In any case, cancel the operation, disconnect the instrument and follow the procedure from the
beginning of this guide.
3
How to verify the correct driver installation
To verify if all the operation has been carried out correctly, open the “Device Manager”
section of the Control Panel of the PC.
Connect the instrument to the USB port.
You should see “Ports (COM e LPT) >> TUSB3410 Device (COM#)” .
The # value is the number assigned to the virtual serial port.
When the USB cable is disconnected, this display disappears and appears again as soon as you re-
connect the cable again.