CATION
ENGINEERING MATERIAL SPECZ
E> WSl)-M1P85-A1/A3
Substance restrictions imposed by lav, regulations or Ford, apply
to the materials addressed by this document. The restrictions are
defined in Engineering Material Specification WSS-M99P9999-Al,
unless a different suffix (e.g., A2 or A3) is specified on the
engineering document fer the application.
4%, APPROVAL OF MATERIALS
Materials defined by this specification must have prior approval by the
responsible Materials Engineering activity. Suppliers desiring approval
of their materials shall first obtain an expression of interest from the
affected Purchasing, Design and Materials Enginesting activity. Upon
Fequest, the Supplisx shall submit to the affected Materials Engineering
activity its own laboratory report to the specification (test results,
not nominal values), the material designation and code number, and test
specizens for Ford evaluation. Upon approval, the material will be added
to the Engineering Material Approved Source List.
5. GENERAL INFORMATION
The information given below is provided for clarification and assistance
in meeting the requirements of the specification.
5.1 SIGNIFICANT SURFACES
Unless otherwise specified on the engineering drawing. significant
surfaces are defined as those surfaces of the finished pert that:
Are directly visible and/or visible by reflection when the
finished part is assembled in position, and/or,
Gan be the source of corrosion products directly visible or
visible by reflection.
5.2 CHROMATE CONVERSION COATINGS
Special finishes may be required on some parts, in which case the
Engineering Drawings will he marked according: zinc plate* plus
chromate treatment; or zinc plate* plus bright finish. or zinc
plate* plus black finish.
*Examp lt Zine plate per WSD-MIP85-Al plus black chromate to
WSB-MLOP10-a2.
WP 3948-5 Page 3 of 3