11.35
Engine monitoring
Water separator
Fig. 2 Sensor water separator
* Press the plug interlock and disconnect the plug
(Deutsch plug)
* Bridge both contacts on the plug of the wiring loom.
[Note
Control light i (Fig. 1) lights up. An audible warning will
sound and the engine is shut down after 2 minutes.
* Push the plug back together, the plug interlock
clicks into place.
* Check the plug interlock by lightly pulling on the wir-
ing loom,
Engine oil pressure
Fig. 3 Ol pressure switch
‘* Press on the locking wire and pull off the plug 4 (Fig.
3),
* Apply the contact to engine ground,
] Note
The control light b (Fig. 1) flashes. An audible warning
will sound and the engine is shut down after 10 sec-
onds.
* Push the plug back on, the plug interlock clicks into
place,
* Check the plug interlock by lightly pulling on the wir-
ing loom.
Engine overheating
Fig. 4 Coolant temperature switch
* Press on the locking wire (Fig. 4) and pull off the
plug.
* Bridge both contacts on the plug of the wiring loom.
[Note
The control light a (Fig. 1) lashes. An audible warning
will sound and the engine is shut down after 2 min-
utes.
* Push the plug back on, the plug interlock clicks into
place,
* Check the plug interlock by lightly pulling on the wir-
ing loom.
Emergency stop switch
STOP?
Fig. S Emergency sop owitch
* Press the emergency stop switch (Fig. 5). The
gine should stop immediately.
368
BOMAG
(008 911 63