Professional Documents
Culture Documents
1. Specification requires one (1) Quality test for every ____ of reinforcing steel bars.
4. Specification requires one (1) Quality test for every ____ of concrete hollow blocks.
5. A document which pertains to the test results and other information relevant to test is called _____
a. Sample Card b. Monthly Materials Report (MMR)
6. How many specimen samples should be submitted in the laboratory for testing concrete hollow block?
a. 8 b. 4 c. 6 d. 3
7. The minimum average compressive strength requirement for non-load bearing concrete masonry unit
is ________.
8. The minimum average compressive strength requirement for load bearing concrete masonry unit is ________.
9. The individual compressive strength requirement for non-load bearing concrete masonry unit is ________.
11. For 325 cans of 4L Latex Paint, how many samples are required to be submitted for Quality testing.
14. If the concrete cylinder is not available for a 2,500 pcs. Culvert pipes, how many pipes shall be subjected to test?
a. 25 pieces b. 50 pieces c. 75 pieces d. 100 pieces
15. A non-load bearing hollow block sample was tested to compression with the following test data.
Width (mm) 150
Height (mm) 200
Length (mm) 400
Load (KN) 252
A galvanized steel sheet samples were tested for the determination of zinc coating with the following test data
A sample of Reinforced Concrete Pipe Culvert has the following laboratory data
20. An estimated 22,200 units of corrugated GI Sheets will be used in the construction of resettlement housing
project, How many quality test are going to prepare?
a. 23 QT b. 22 QT c. 1 QT d. 2 QT
21. What is the required length pipe specimen in the determination of zinc coating of galvanized pipe?
22. The minimum wall thickness of GI pipes at any point shall be not more than of ________ under the nominal
wall thickness specified.