Professional Documents
Culture Documents
Properties of WT 5 x 6: a. 100 mm
y̅ = 34.54 mm b. 150 mm
c. 200 mm
6. Which of the following most nearly d. 250 mm
gives the allowable strength 10. Which of the following most nearly
based on yielding? gives the compressive strength of
a. 566.43 kN concrete?
b. 339.18 kN a. 600.56 kN
c. 509.79 kN b. 701.39 kN
d. 305.26 kN c. 882.45 kN
7. Which of the following most nearly d. 660.78 kN
gives the design strength based 11. Which of the following most nearly
on rupture? gives the nominal moment capacity?
a. 315.79 kN a. 365 kN-m
b. 378.95 kN b. 343 kN-m
c. 444.74 kN c. 329 kN-m
d. 473.69 kN d. 313 kN-m
8. Which of the following most nearly
gives the ultimate strength based Situation 5: A 2 m x 2 m footing carries
on block shear? concentrically a square column of 0.4 m x
a. 731.72 kN 0.4 m.
b. 697.55 kN Design data:
c. 713.27 kN Column factored loads:
d. 679.55 kN DL = 580 kN
LL = 440 kN
Situation 4: A reinforced concrete Concrete cover to the centroid of footing
beam has a cross-section as shown. reinforcement = 100 mm
Use f’c = 30 MPa, fy = 345 MPa, and Concrete, f’c = 28 MPa
A = 2033 mm2. The diameter of the Steel, fy = 415 MPa
rebar is 20 mm and the concrete cover Allowable stresses at ultimate loads:
is 60 mm. For diagonal tension or two-way action
shear = 1.76 MPa
For wide beam shear = 0.88 MPa
Maximum steel ratio for moment = 0.021
12. Which of the following gives the
minimum thickness (mm) of footing
required for diagonal tension?
a. 400 c. 450
b. 350 d. 500
13. Which of the following gives the
minimum thickness (mm) of footing
required for beam shear?
a. 400 c. 350
b. 300 d. 250
14. Which of the following gives 17. Which of the following most nearly
the minimum thickness (mm) of gives the maximum shear in span FG due
footing required for design to dead load and live load?
moment? a. 58.50 kN
a. 450 c. 400 b. 50.87 kN
b. 300 d. 250 c. 61.12 kN
d. 54.05 Kn
Situation 6: Given the following
data for the floor plan shown. 18. Compute the critical net area of the
L150x100x12 section with M22 bolts in
the connection shown. Area of the
angular section is 3,064 mm2.