Professional Documents
Culture Documents
Staiger Mohilo
Industrielle Messtechnik und Prüfsysteme
1. Application
l geological applications
l Made of stainless steel
This force sensor type is designed as a flat, circu- l Optional standardization of the rated
lar disc. The load application knob for receiving characteristic
compressive forces is an integral part of the
sensor.
mic performance:
recommended 50 % of capacity
permitted 70 % of capacity
Mounting:
Bottom side with three 3 mm (M 2.5) or 6 mm (M 4) deep mount-
ing holes on diameter T, sharing 120°, see table.
Material: High-grade stainless steel 1.4542
Electrical connection:
Excitation:
Pin connection:
Measuring range 0 ... 1000 N max. 5 V DC
Pin wire signal
Measuring range 0 ... 2000 N max. 10 V DC
Output: 1.5 mV/V, nominal* 1 brown excitation -
Calibration resistor: 80 k ± 0,1 % 2 white excitation +
The bridge output voltage, resulting from a shunt of this value, is 3 (blank) shield
stated in the calibration certificate. 4 yellow signal output +
*Deviations from the stated value are possible. 5 green signal output -
Mechanical specifications
Non-linearity:
5. Order Information
e.g Compressive-force load cell, 0...100 kN:
Measuring range 0 ... 1 kN < 0.25 % F.S.
Measuring range 0 ... 2 kN < 0.5 % F.S.
108526 – 100 kN – 12971 – 1
Hysteresis:
Measuring range 0 ... 1 kN < 0.15 % F.S.
Measuring range 0 ... 2 kN < 0.5 % F.S. Data sheet Meas. range Art.-No. Option 1mV/V
Repeatability: < 0.1 % F.S.
108526