You are on page 1of 4

Sunburnt

By Nidhi Kansal

A quick and light knit, this crescent shaped shawlette has a lacy edge and is worked from the bottom up.

Finished Measurements: Length between tips: 50” [125cm], depth: 12” [30cm]

Yarn: 2 skeins of Garnstudio DROPS Alpaca (183 yds [167m], 100% alpaca, 50 gms) or approx. 350
yds or [320m] in sport weight. Shown here in colorway 2020 Light Camel.

Needles: US size 7 [4.5mm] needles

Notions: Use markers or a lifeline for the lace part, if required.

Gauge: 16 sts and 32 rows = 4”  [10cm] in st st after blocking

_____________________________________________________________________________________
Sunburnt – Nidhi Kansal 1  
Chart:
Note: Slip 1st st of RS and WS throughout. (These 2 edge sts are not shown in the charts below.)

1. Lace pattern is worked on 305 sts throughout.


2. Pattern repeat is marked in red i.e.
a. For rows 1 – 12: bet sts 7 – 24
b. For rows 13 – 24: bet sts 4 - 21
3. For Rows 1 – 12: work repeat till 14 sts remain (not including edge st)
4. For Rows 13 – 24: work repeat till 11 sts remain (not including edge st)

_____________________________________________________________________________________
Sunburnt – Nidhi Kansal 2  
Lace Pattern: (Worked on a multiple of 16 sts +1)
Note: Slip 1st st of RS and WS throughout the pattern. (These 2 edge sts are not included below.)
R1: K across
R2 and all WS rows: P across
R3: (K1, yo)x3, *(ssk)x2, sl2tog-k1-p2sso, (k2tog)x2, yo, (k1, yo)x5; rep from * to last 14sts, (ssk)x2, sl2tog-k1-
p2sso, (k2tog)x2, (yo, k1)x3
Rep R1 to R4 twice more
R13: K across
R15: (K2tog)x3, *(yo, k1)x5, yo, (ssk)x2, sl2tog-k1-p2sso, (k2tog)x2; rep from * to last 11 sts, (yo, k1)x5, yo,
(ssk)x3
Rep R13 to R16 twice more.

Abbreviations:
k2tog: knit 2 sts together
k2togtbl: knit 2 sts together through the back loop
LHN: left hand needle
p2tog: purl 2 sts together
sl1: slip 1 st k-wise on RS row or p-wise on WS row
sl2tog-k1-p2sso: slip 2 sts together as if to k2tog, k1, pass the 2 sl sts over one by one
ssk: slip, slip, knit the 2 slipped sts together
yo: yarn over

Begin pattern.
CO 307 sts.
This includes 1 edge st on either side. Sl first st of each RS row k-wise and each WS row p-wise throughout the
pattern.
Lace pattern is worked on 305 sts.

Work rows 1-24 of lace pattern (slipping 1st stitch of each row).

R25: Sl1, k15, k2tog, (k14, k2tog)x17 times, k17. (289 sts)
R26: Sl1, p15, p2tog, (p13, p2tog)x17 times, p16. (271sts)
R27: Sl1, k14, k2tog, (k12, k2tog)x17 times, k16. (253 sts)
R28: Sl1, p14, p2tog, (p11, p2tog)x17 times, p15. (235 sts)

Begin short rows.


RS: Sl1, K120, turn.
WS: P7, turn.
RS: K6, ssk, k3, turn.
WS: P9, p2tog, p3, turn.
RS: K to 1 st before turning point, ssk, k3, turn.
WS: P to 1 st before turning point, p2tog, p3, turn.

Repeat the last 2 rows till 1 st left on each side.


_____________________________________________________________________________________
Sunburnt – Nidhi Kansal 3  
RS: K till 2 sts remain, ssk.
WS: P till 2 sts remain, p2tog. (All sts, including edge sts, are now worked.)

Bind off on RS as follows: *K2togtbl, place this worked st back on LHN; rep from * till end.

Finishing: Weave in ends and block aggressively.

Copyright:
This pattern is intended for personal use only. The contents of this pattern are subject to copyright. You may not
distribute or sell copies of this pattern without consent of the designer Nidhi Kansal.

_____________________________________________________________________________________
Sunburnt – Nidhi Kansal 4
 

You might also like