Professional Documents
Culture Documents
Network equipment
3.5 Management Center
a. Intercom with indoor monitor and outdoor station.
b. Monitor the outdoor station.
c. Remote unlock the door for visitor.
Management software
a. Send Message
b. Data Management, such as IC/ID card, Intercom record. Etc.
c. Alarm message.
3.6. Network Signal Switcher, Model: 602VAP
8 ports, with audio/video separation and signal repeat function. It is mainly applied
to the signal switch of the networking main line. When outdoor stations are far way
from the Management center, use this equipment to connect between outdoor
stations and Management center to save cables.
3.7.Wall station,
The feature is almost same as normal outdoor station, except it can call all indoor
monitors of the community, not just call one building indoor monitors. And we install it
at the gate of the whole community.
3.8 .Center switch, Model :AB-602DST
4 ports of the switch are connected to building Bus (outdoor stations or VAP), the
other four ports are connected to management center or Wall station. It reaches the
function of channel switch.
3.9 .Signal repeater, Model: AB-602SR
Extending networking function to realize the signal repeat in the community. It
need to configure 1 pc When the network signal wire comes to be over 600 meters
long.
Remark:
when need to use this equipment, usually the community will be very larger, we
strongly suggest to send us the whole location drawing for our double check
4.0 Project configuration
System configuration
Position configuration
4.1 Project Description:
There is a residential area with 3 buildings, each building has 9 floors, there are 3
households in each floor from floor 1~8, and in last floor there is only one household.
There are two entrance, front door and back door.
From 1-9 floor, each household have an indoor monitor.
There is a management center at the door keeper, and there is a wall station at the
main entrance.
4. 2 Configuration
Please see PDF file.
5.0 Trouble Shooting
Malfunction Phenomenon Elimination Method
Unlocking error A. Check if the indoor switch button works
properly.
B.Check if the reverse diode from outdoor
station which is linked to lock connected
correctly or not.
C.Check if the connection between lock
and outdoor station is correct or not.
Outdoor station calling indoor monitor, but Check isolator address/room number
indoor monitor doesn’t ring and doesn’t setting to see whether the address/room
have image number is correct.
Outdoor station calling indoor monitor, A, Check whether the output of isolator
indoor monitor rings but has no image module’s power port is 15v.or not.
B,Check the video wires between the
indoor monitor and isolator module. Or
between outdoor station and isolator
module. Is connected normally.
C. Check if the video wires and GND is
short circuit.
Outdoor station calling indoor monitor, the Check whether the video matching switch is
image is not clear. on or not. Or Check the protection film
covered on the outdoor station camera is
taken off or not.
The volume of indoor monitor is small Try to adjust the volume switch to see if the
volume is changed.
Super Apartment System
1.0 What’s different features between Standard and Super Apartment System
Please see PDF file:
Alarm:
Support max.8 alarm stations. The gas detector and Emergency button
will always be in the working status. Other detector can be set according to
user’s requirement. Once the detector triggered, the video indoor phone and
management. Alarm message can be sent to management center
automatically, and management center can check the alarm types, time,
place and resident information through the remote computer control。
Image Memory:
Support snapshot, can store more than 100 pictures in SD card.
Telephone module:
use regular telephone to talk with outdoor station and unlock the door
Guard Station:
The indoor monitor can call the Guard Station. Available model: F4.
Flat Door camera for each household:
When the visitor enter the building and arrive before your door, he can
have video intercom with indoor monitor again, so that can be “double
security”.
Note:
The indoor monitor with the alarm station detector has the power interface to
supply the power for the alarm station detector, this interface can supply the current
up to 12V @ 100mA. If the whole consumption for this detector is over this value, it
is better to use extra power supply to supply the power for alarm station detector.